|
Big Block Talk! Everything about swapping a big block engine into your cart! |
|
Thread Tools | Display Modes |
01-26-2013, 01:34 PM | #1 |
Getting Wild
Join Date: Sep 2007
Posts: 109
|
Gas in oil
Has anyone had a problem with the 20hp Honda and gas in the oil? I pulled the carb cleaned and checked everything but didn't find anything. Is it possible for the pulse fuel pump to leak fuel into the vacuum tube?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-26-2013, 01:39 PM | #2 |
Gone Wild
Join Date: Sep 2011
Location: ARIZONA
Posts: 476
|
Re: Gas in oil
Check the carb float pin, it's probably worn.
|
01-26-2013, 01:43 PM | #3 |
Getting Wild
Join Date: Sep 2007
Posts: 109
|
Re: Gas in oil
Pulled it all out last night and everything looked good
|
01-27-2013, 02:15 PM | #4 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: Gas in oil
Gas in oil from leaking carb or leaking pulse pump to the crankcase....usually one of those.
|
01-27-2013, 03:48 PM | #5 |
Getting Wild
Join Date: Sep 2007
Posts: 109
|
Re: Gas in oil
Thanks I thought it might be the pump but a local shop said it couldn't get through there to the oil
|
01-27-2013, 04:09 PM | #6 |
Vegas modded 420
Join Date: Jun 2009
Location: West MI
Posts: 15,445
|
Re: Gas in oil
It can if the diaphragm in there goes bad, and usually they are not expensive, if that is the problem and its not the carb.
|
01-27-2013, 04:17 PM | #7 |
Getting Wild
Join Date: Sep 2007
Posts: 109
|
Re: Gas in oil
is the pump rebuildable or do I need to buy a whole pump
|
01-30-2013, 02:00 PM | #8 |
Getting Wild
Join Date: Sep 2007
Posts: 109
|
Re: Gas in oil
Found a OEM Honda fuel pump for $20 so hopefully that solves the problem and I don't have any damage from the contaminated oil.
|
02-21-2013, 06:12 PM | #9 |
Getting Wild
Join Date: Sep 2007
Posts: 109
|
Re: Gas in oil
Replaced the fuel pump and changed oil two times. Took carb back off and double checked parts for wear and seal also set float a bit lower. Have about 1/2 hour run time on new oil and the oil appears to be contaminated again. The engine starts and runs good I can't imagine that much fuel going through the carb and not flooding the engine. I did take the old pump apart and found both sides of the diaphragm wet but couldn't find a hole.
|