04-15-2019, 05:32 AM | #1 |
Not Yet Wild
Join Date: Nov 2017
Posts: 4
|
420cc predator key switch wont engage start and wont charge
Hey everyone I swapped a 420 predator in my 1997 club car. I cut the wiring harness and extended it to the dash haven't had a problem with it for 2 or 3 months until yesterday. Went for quick ride the volt meter showed it was charging got back home shut it off and then nothing starter wouldn't turn over . I took a jumper wire and turn the key on touched the started fired right up and noticed it wasn't charging. checked all the wiring connections all seemed fine . Anyone have any ideas ? Thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-15-2019, 06:19 AM | #2 |
Gone Wild
Join Date: Jun 2011
Location: Northern Indiana
Posts: 2,827
|
Re: 420cc predator key switch wont engage start and wont charge
I know you've already said "wiring connections all seemed fine", but it sounds like something has broken contact somewhere. Pulled or melted wire in the middle of a run? Maybe a solenoid issue, but I'm not certain just how you have it wired. I've done a couple 420 swaps and just connected them to the cart's original wiring - original solenoid, starter generator, voltage regulator and all.
|
04-15-2019, 06:49 AM | #3 |
Crazy Ole Man
Join Date: Jan 2016
Location: Owego NY
Posts: 2,758
|
Re: 420cc predator key switch wont engage start and wont charge
What type connectors did you use? I suggest soldering all your connections then heat shrink to seal it up. Anything less will lead to the problems your experiencing now.
|
04-15-2019, 06:53 AM | #4 |
Not Yet Wild
Join Date: Nov 2017
Posts: 4
|
Re: 420cc predator key switch wont engage start and wont charge
Yea Meimk I felt certain something had come loose or chaffed . I cut the wiring harness on the 420 and just extended it to the dash . I Even took my fluk meter and rang all the wires out didn't have any funky reading . thanks for the reply
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Solenoid wont engage | Electric EZGO | |||
ez go marathon wont start and possibly a switch bad??? | Gas EZGO | |||
My G1 wont engage the drive axle | Gas Yamaha | |||
Drive wont engage | Gas Club Car | |||
Clutch wont engage | Gas EZGO |