lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 12-11-2014, 10:22 AM   #1
Not Yet Wild
 
Join Date: Aug 2013
Posts: 17
Default Quit running

Drove over to the storage box across the yard. Everything working perfectly. Got what I needed and Drove off then got about 10 feet and it went dead in the water, made popping noise and quit very suddenly. If it was my pick up I would say the drive shaft u-joint broke. Now the only thing working is the back up alarm.Electric motor dead as a door nail. This is a Club Car 48V. Checked the wires going to motor posts and they look tight and not corroded. Any suggestions as where to look next. Thanks
tjcnok is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 12-11-2014, 11:52 AM   #2
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,976
Default Re: Quit running

Serial number of cart will help. Just above go pedal under dash.

Pull hard on all battery cables. Check voltage. If it has tow/run switch, put in tow before working around batteries.
mrgolf is offline   Reply With Quote
Unread 12-11-2014, 01:47 PM   #3
Gone Wild
 
jjance's Avatar
Club Car
 
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
Default Re: Quit running

It sounds to me like you stalled the motor. What was it that you went across the yard to get? I hope it wasn't big and heavy.
jjance is offline   Reply With Quote
Unread 12-11-2014, 01:56 PM   #4
DS Drivers Club Founder
 
CCFanatic's Avatar
Club Car
 
Join Date: Jul 2013
Location: Upstate NY
Posts: 3,408
Default Re: Quit running

He has a 95 Series 48V. Found from an older post
CCFanatic is offline   Reply With Quote
Unread 12-11-2014, 02:58 PM   #5
Getting Wild
 
jfsegar's Avatar
E-Z-GO
 
Join Date: Aug 2014
Location: SC
Posts: 133
Default Re: Quit running

I had a CC and one time the connection below the accelerator pedal came loose. It was dead in the water like you said until I reconnected it again. That was after I ran over something.
jfsegar is offline   Reply With Quote
Unread 12-24-2014, 11:13 AM   #6
Not Yet Wild
 
Join Date: Aug 2013
Posts: 17
Default Re: Quit running

Sorry it took so long to get back. Been real hectic lately! Mr. Golf got it exactly right! Battery cable went bad. Replaced all the cables and every thing is good again. Out of the dog house, she still looks worried if I step too close to her machine. Thanks everyone!
tjcnok is offline   Reply With Quote
Unread 12-24-2014, 12:06 PM   #7
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,976
Default Re: Quit running

You may be telling someone else to check their battery cables sometime in the future that is how I found out.
mrgolf is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Just Quit Running Clone Engine Swaps
Quit running Gas EZGO
G14E quit running Electric Yamaha
got it running then quit Gas EZGO
quit running Electric Club Car


All times are GMT -5. The time now is 05:03 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.