lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 11-14-2008, 08:29 AM   #1
Not Yet Wild
 
Join Date: Nov 2008
Posts: 10
Question Runs then just stops

]Hi All
i have a 1992 Electric Club Car 36V that will stop or lose power while in forward and reverse. things i have done to fix are, check and clean batterys and load test OK , removed forward and reverse switch cleaned and checked micrco switches OK, cleaned and ckecked micro switch in V-glide OK, replaced silenoid with new, cleaned ALL terminal conectors from motor, controler,forward & reverse, to v-glide All checks out Ok but it will still stop or lose power. controller is my last resort
Denny
Denny is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-14-2008, 08:59 AM   #2
Not Yet Wild
E-Z-GO
 
Join Date: Sep 2008
Location: Troy IL.
Posts: 48
Default Re: Runs then just stops

does the cart pick up power again while you are still moving or some times nothing then takeoff. mine acted same way I had a broken lead on one of the carbon brushes in the electric motor
ez rider 95 is offline   Reply With Quote
Unread 11-14-2008, 09:16 AM   #3
Not Yet Wild
 
Join Date: Nov 2008
Posts: 10
Default Re: Runs then just stops

hi EZ rider 95
thanks for your reply how do you check for carbon brush leads broken ?
Denny is offline   Reply With Quote
Unread 11-14-2008, 09:27 AM   #4
Not Yet Wild
E-Z-GO
 
Join Date: Sep 2008
Location: Troy IL.
Posts: 48
Default Re: Runs then just stops

I took a hammer and lightly tapped on brush motor housing while accelerator was pushed and making sure nothing was in front of where I was going if cart moved
ez rider 95 is offline   Reply With Quote
Unread 11-14-2008, 09:40 AM   #5
Not Yet Wild
 
Join Date: Nov 2008
Posts: 10
Default Re: Runs then just stops

thanks ez rider i will give it a try i sure dont want to buy a controller at $450.00
Denny is offline   Reply With Quote
Unread 11-14-2008, 09:52 AM   #6
Not Yet Wild
E-Z-GO
 
Join Date: Sep 2008
Location: Troy IL.
Posts: 48
Default Re: Runs then just stops

you are right about that it may not work but it wont cost anything to find out other than a little time good luck
ez rider 95 is offline   Reply With Quote
Unread 11-14-2008, 05:37 PM   #7
Not Yet Wild
 
Join Date: Nov 2008
Posts: 10
Default Re: Runs then just stops

well ez rider, tapped,banged, schock, no help ? only thing i think it could be is the controller ? i found on line i can send my old controller in and have it rebuilt for $181.00 guess thats what i may do. thanks for your help no one else had any ideas
Denny is offline   Reply With Quote
Unread 11-14-2008, 05:41 PM   #8
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Runs then just stops

denny it could be the F&R switch itself going bad.....thats one thing they will do they will run ok than won,t than run than won,t.........dosn,t matter how good you clean it if its going bad it won,t any difference........................also check the cables goling to the switch i have seen this happen quite a few times because one of the cables from all the movement will slowly start falling apart and its hard to tell so look at them good.....................................
shadowman is offline   Reply With Quote
Unread 11-14-2008, 07:00 PM   #9
Not Yet Wild
 
Join Date: Nov 2008
Posts: 10
Default Re: Runs then just stops

TOM thanks for helping me wires are very good I bent,shook and did a "condanuity" bad speller. test ok. but i dont know about the f&r switch i took it off and apart cleaned and put back on when hooked up with key on it klicks both forward and reverse I just dont know ?
Denny
Denny is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Club car stops Help Electric Club Car
Cart Just Suddenly Stops Running! Electric Club Car
G2 stops running Gas Yamaha
'03 EZ PDS; New Batteries; Intermittent stops Electric EZGO
EZ GO starts then stops then just clicks. Electric EZGO


All times are GMT -5. The time now is 06:32 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.