lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 11-15-2008, 10:56 AM   #1
Not Yet Wild
 
Join Date: Nov 2008
Posts: 2
Default Club Car under water

I picked up a 48 volt Club Car that was under water

I pulled the motor and had it cleaned, I also drained the differential

I want to find a source where I can get free service manual information and wiring diagrams to aid me in this rebuild

I would like to strip it down more to make sure all the water is gone

Also I would like to find out if the batteries can be refurbised by replacing the acid

Here is the modle information

Part# 101772801
Model# 5BC58JB56163A

Any help on this matter would be greatly appreciated

Thank you for your help Beatnick

Last edited by beatnick; 11-15-2008 at 10:59 AM.. Reason: incorrect information
beatnick is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-15-2008, 12:35 PM   #2
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Club Car under water

you can get diagrams here you need the year and the elec. system, as for a manual you can download as far as i know you won,t find one for C.C. your wasting your time and money if the batteries were all contaminated with any dirty water but other than the controller if it has one you may just need to let the cart sit and dry out...................how long was it under water?....................................
shadowman is offline   Reply With Quote
Unread 11-15-2008, 11:59 PM   #3
Golf Cart Photographer
 
rusty's Avatar
Club Car
 
Join Date: Jan 2007
Location: Wichita Falls Texas - My Ride 2010 Club Car
Posts: 6,238
Default Re: Club Car under water

Welcome to the forum beatnick...................
rusty is offline   Reply With Quote
Unread 11-16-2008, 02:32 AM   #4
Getting Wild
 
turktrax's Avatar
Club Car
 
Join Date: May 2008
Location: North Louisiana
Posts: 122
Default Re: Club Car under water

Here is a link for your wiring diagrams from the electric club car section of this forum. I would not try to run anything on the cart until you are certain everything is completly dry. Then you can find out what is good and what needs to be replaced. Just let the batteries stay discharged or at least disconnect them to keep from shorting out your electronics. Hopefully you wont have to get too deep into your wallet.

Electric Club Car wiring diagrams
turktrax is offline   Reply With Quote
Unread 11-16-2008, 10:18 AM   #5
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: Club Car under water

beatnick,
it also makes a big difference on what type of water it was , salt water is worse than fresh water.
If it was salt water and it was submurged long enough for the water to start wicking into the cables, then replace all battery cables and main moter cables with 4 Ga. .
It will keep you from having little unknown problems popup later on.

And as I always do, if you plan on keeping the cart for a while , I recommend you buy the Club Car Maint./Service Manual. It will be the best $20. you'll ever speend, all Diagrams and troubleshooting test procedures for 90% of the problems.

Good luck
GLEEMO is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
battery water help Electric EZGO
Cart under water (IKE) Electric Club Car
distilled water Electric EZGO
Water Lifted Golf Carts


All times are GMT -5. The time now is 10:34 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.