|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-16-2008, 07:12 PM | #1 |
Not Yet Wild
Join Date: Nov 2008
Posts: 3
|
wiring problem on 91 DS
I need a wiring diagram for a 91 DS electric V glide. The cart is dead. I found a broken wire (light Blue). One end comes from the For/Rev switch. I cant find where it goes to. I searched with the limited time available but was unable to find any other broken wire or terminal. I purchased it as a used cart and have never had the pleasure of fixing a golf cart before. I found a print on the net but it doesn't have the wire colors detailed. I suspect that the Blue wire goes to the on/off switch. What I do know is that when I put the cart in REV the buzzer works. Will the buzzer work with the key OFF? I don't have access to my cart until tomorrow morning to check the buzzer with the key on and then off. Thanks in advance for any help.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-16-2008, 07:23 PM | #2 |
Not Yet Wild
Join Date: Aug 2008
Posts: 14
|
Re: wiring problem on 91 DS
welcome to the forums Club. I'm new to this myself, but I'm working on the same kind of cart you are. I believe that the blue wire on your FNR switch is from your ignition. If its a thin wire, check the microswitch on the top of your FNR to see if the wire terminal is still there connected to the ms lead. If so, there should be a yellow wire attached to the other lead on the switch. Hope this helps you out and saves the pros here a little time. If not, one of them will be along shortly to save you. They're really helpful around here.
|
11-16-2008, 09:17 PM | #3 |
nimda
Join Date: Jun 2007
Posts: 13,022
|
Re: wiring problem on 91 DS
There are wiring diagrams at the top of each forum in the stickies. If you can't find one let us know.
|
11-16-2008, 10:07 PM | #4 |
Not Yet Wild
Join Date: Nov 2008
Posts: 3
|
Re: wiring problem on 91 DS
Thanks for the info on the sticky's diagrams. I already have that print and it's very helpful but it doesn't show the wire colors. It does however show numbers which would be great if I had a guide to the numbering system. I have no experience with golf carts. I fix airplanes. I would like to check all of the wiring on my cart by wire guage and color to make sure it matches a known good diagram. The broken wire (blue) that I found looks like it was cut not broken per se, but the conductor (wire) doesn't seem to have a shine. Overall the wiring looks really rough, corrosion clearly evident. After I get it running I will be replacing most of the wiring. I'll probably do it a few wires at a time by guage. I'll probably buy some good wire and terminals. Any advice on where to purchase these items. If I can find correct wires already to go at a good price I'd rather do that. I've seen cable sets for batteries on ebay, not sure of quality but the prices are fairly cheap. Thanks again, CC91
|
11-21-2008, 05:59 PM | #5 |
Not Yet Wild
Join Date: Nov 2008
Posts: 3
|
Re: wiring problem on 91 DS
cart fixed. found bad switch in v glide. thanks for the help. cc91
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Wiring Problem on my Cushman | Electric golf carts | |||
1980 ezgo wiring problem | Electric golf carts | |||
Charging and wiring problem | Electric Club Car | |||
'97 club car motor wiring problem | Electric Club Car |