lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 02-25-2015, 04:49 PM   #1
Getting Wild
 
wards75's Avatar
Club Car
 
Join Date: Oct 2012
Location: Eastern NC
Posts: 141
Default Forward but no reverse..

OK, so I replaced 2 ring connectors on my F&R because the heat shrink and connector looked ragged. Did them one at a time and after I was done I put the neg cable back on and was gonna take it for a spin but I got no reverse...it'll go forward but that's it. Just clicks in reverse...
Pack voltage is ~51 volts and I tried jumping the reversing micro switch but when I do that I have no forward or reverse.
Took the F&R apart and checked contact points and all my connections are fine...??
Is it time for a HD F&R or am I missing something? Only other thing I did was found the reverse buzzer and unplugged it but that doesn't have any effect on it right? Be pretty silly if it did...

(2002 CC DS 48v)
Thanks
wards75 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 02-25-2015, 06:51 PM   #2
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,561
Default Re: Forward but no reverse..

Make sure You did not get your micro switch wires crossed.

The reverse buzzer micro switch is #2 (the middle one) it connects to Orange and Red/White fron the harness.

It does not cause any problems being disconnected, but for safety, it may be better to just wrap some electric tape around the buzzer to muffle the sound.

The 1/2 reverse micro switch is #3 (furthest away from FNR body), it has 3 wires: Green, White and Black.

In Forward, Green is connected to White (full speed).

In Reverse, Green is connected to Black (1/2 speed).

The Black wire has a resistor in the harness that if broke could cause problems in reverse.

To by-pass the 1/2 speed switch and have full speed in forward and reverse, jump the Green and White wires from the harness.

Edit: The diagram in the stickies is not very clear, here is a High Resolution wiring diagram for Your cart:

http://www.buggiesgonewild.com/attac...car_ds_48v.jpg

Last edited by Sergio; 02-25-2015 at 07:02 PM.. Reason: Wiring Diagram Link
Sergio is online now   Reply With Quote
Unread 02-25-2015, 07:10 PM   #3
Getting Wild
 
wards75's Avatar
Club Car
 
Join Date: Oct 2012
Location: Eastern NC
Posts: 141
Default

Thanks Sergio, I'll see what I can figure out!
wards75 is offline   Reply With Quote
Unread 02-25-2015, 07:43 PM   #4
Getting Wild
 
wards75's Avatar
Club Car
 
Join Date: Oct 2012
Location: Eastern NC
Posts: 141
Default

OK, so my red/white wire was crossed on my #2 switch...I have no idea how that happened cause like I said, after I changed connectors out, I hooked neg cable back up and was gonna go for a spin...I didn't even mess with the micro switches until it wldnt reverse then I staters...strange!?
Anyway...thanks for the wiring diagram Sergio and thanks for the clarity! If it weren't for the members here I'm sure a lotta folks wld be lost!!
wards75 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2006 ezgo forward is reverse and reverse is forward please help Electric EZGO
Reverse alarm sounds in Forward, wont go forward or reverse Electric Club Car
Reverse alarm stuck - motor won't run forward or reverse Electric EZGO
Alarm sounding in forward. No movement in forward or reverse Electric Club Car
Forward Reverse switch melted on forward...have question about replacement part Electric Club Car


All times are GMT -5. The time now is 06:04 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.