|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-30-2015, 05:24 PM | #1 |
Not Yet Wild
Join Date: Mar 2015
Posts: 3
|
Sluggish going forward
I have a 48V 2000 Club Car DS that I purchased used last year. I also installed 6 new batteries last year. When I place the cart in forward it is very sluggish and has a hard time starting out. I then placed it in reverse and the cart ran perfectly fine. Can someone please assist me with this? I am mechanically inclined however I don't know much at all about an electric golf cart.
Thanks |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-30-2015, 07:05 PM | #2 |
Cave Dweller
Join Date: Apr 2013
Location: Always On The Move
Posts: 22,239
|
Re: Sluggish going forward
I would start with connects at the motor and then take a good look at the f/r switch cable and inner contacts
|
03-30-2015, 07:51 PM | #3 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: Sluggish going forward
You may have the f r sw wired wrong. The cable for the rev may be on fwd and fwd on rev.
|
03-30-2015, 07:59 PM | #4 |
Not Yet Wild
Join Date: Mar 2015
Posts: 3
|
Re: Sluggish going forward
I will check all that is suggested. I haven't made any mechanical changes to the cart so hopefully the wires aren't crossed. I was also told that even though the batteries were purchased new last year that one could still have gone bad. Is it true that a cart usually only uses around 18V in reverse, which means it would run fine? If so, maybe I do have a bad battery?
|
03-30-2015, 08:02 PM | #5 |
DS Drivers Club Founder
Join Date: Jul 2013
Location: Upstate NY
Posts: 3,428
|
Re: Sluggish going forward
|
03-31-2015, 02:29 PM | #6 |
Not Yet Wild
Join Date: Mar 2015
Posts: 3
|
Re: Sluggish going forward
Well, it turns out that I had 1 bad battery. Five of my batteries, new last year, tested between 8.5 and 8.9. The sixth battery was only 4.9. Exchanged the battery and now the cart runs as it should. Thanks for your assistance and to CCFanatic for the wiring diagram.
|
03-31-2015, 02:43 PM | #7 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Sluggish going forward
If that was the pack positive battery, make sure You have the charger receptacle red wire connected to that battery.
I have seen a few times new batteries go bad because they were never charged. |
03-31-2015, 02:43 PM | #8 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: Sluggish going forward
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Sluggish DS | Gas Club Car | |||
EZ Go sluggish in forward run | Gas EZGO | |||
little sluggish | Gas EZGO | |||
Forward Reverse switch melted on forward...have question about replacement part | Electric Club Car | |||
Sluggish | Electric Club Car |