Buggies Gone Wild Golf Cart Forum

Buggies Gone Wild Golf Cart Forum (http://www.buggiesgonewild.com/)
-   Electric Club Car (http://www.buggiesgonewild.com/electric-club-car/)
-   -   Nowhere to plug in my new light kit (http://www.buggiesgonewild.com/electric-club-car/107515-nowhere-plug-new-light-kit.html)

jvanhees 06-24-2015 11:00 PM

Nowhere to plug in my new light kit
 
Hey Guys - bought a light kit and I have nowhere to plug in the 12 pin, or the 9 pin for headlights.

First step in my directions after installing the push/pull switch is to plug the male 12 pin into the female 12 pin on the existing vehicle harness.

I don't think I have one. All I have behind the dash is pictured below. What do I do now? The description made it look like it was a plug n play.

2007 precedent 48 volt
http://i612.photobucket.com/albums/t...94245C2FC2.jpg
http://i612.photobucket.com/albums/t...A7A193207C.jpg

jvanhees 06-24-2015 11:02 PM

Re: Nowhere to plug in my new light kit
 
This is how mine is supposed to plug in


stang99x 06-24-2015 11:05 PM

Re: Nowhere to plug in my new light kit
 
07 was the last year of the prewired carts for lights. Some had it, some didn't. I don't see the plug (it'd be over by the passenger side where the other one is) You can pull up the floor mat and see if there is another wire in the little channel going up to the dash, but not then you'll need the full harness along with the light kit. The part you need will have the rear lights turnsignals brakes setup, wiring connection for brakes and main power ground for the lights. What maker did you get it from?

jvanhees 06-25-2015 08:54 AM

Re: Nowhere to plug in my new light kit
 
Quote:

Originally Posted by stang99x (Post 1170199)
07 was the last year of the prewired carts for lights. Some had it, some didn't. I don't see the plug (it'd be over by the passenger side where the other one is) You can pull up the floor mat and see if there is another wire in the little channel going up to the dash, but not then you'll need the full harness along with the light kit. The part you need will have the rear lights turnsignals brakes setup, wiring connection for brakes and main power ground for the lights. What maker did you get it from?

Thanks Stang - I bought it on ebay from 3R Sales in Ohio.

Just hung up with them and it sounds like I'm missing my entire vehicle harness. Lovely. :roll:

So where do I get the whole vehicle harness?
Or do I just need a bucket harness?

jvanhees 06-25-2015 09:17 AM

Re: Nowhere to plug in my new light kit
 
Just spoke to a club car dealer, and she didnt know what was going on.

She made it sound like I need the bucket harness, but had no idea.

Sergio 06-25-2015 09:24 AM

Re: Nowhere to plug in my new light kit
 
Call a different dealer....

You just need the bucket harness, although they only stopped adding those to the club cars in January 2008, so if yours is missing, someone took it off.

jvanhees 06-25-2015 10:38 AM

Re: Nowhere to plug in my new light kit
 
Quote:

Originally Posted by Sergio (Post 1170343)
Call a different dealer....

You just need the bucket harness, although they only stopped adding those to the club cars in January 2008, so if yours is missing, someone took it off.

I watched how to install a bucket harness, and you need to install the bucket harness to the factory harness in front - which there is no factory harness that runs up to front bumber.

https://www.youtube.com/watch?v=QPkIB0re1xM

Sergio 06-25-2015 11:04 AM

Re: Nowhere to plug in my new light kit
 
The harness that runs to the headlight comes with the light kit.

The bucket harness has the tail light wires, brake pedal partial wires, and a +48v feed to the front dash.

It ends with the 12pin connector that comes up from the floor board on the passenger side channel behind the cup holder.

Take a picture or post a link of what you bought.

jvanhees 06-25-2015 01:52 PM

Re: Nowhere to plug in my new light kit
 
Quote:

Originally Posted by Sergio (Post 1170371)
The harness that runs to the headlight comes with the light kit.

The bucket harness has the tail light wires, brake pedal partial wires, and a +48v feed to the front dash.

It ends with the 12pin connector that comes up from the floor board on the passenger side channel behind the cup holder.

Take a picture or post a link of what you bought.

Thanks Sergio - Here is the link.

http://www.ebay.com/itm/381139593662...%3AMEBIDX%3AIT

I can post a picture later on today.

You make a lot of sense, and it looks like you are right! Thank you.

Sergio 06-25-2015 02:36 PM

Re: Nowhere to plug in my new light kit
 
This is from the same vendor but includes the "bucket harness".

http://www.ebay.com/itm/Club-Car-Pre...-/381139776616

Perhaps you can send them an email and see if they will sell you the bucket harness for the difference in money.

You will also need a 48v-12v voltage converter.


All times are GMT -5. The time now is 04:35 PM.

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2018, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.