lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 06-29-2015, 10:43 PM   #1
Not Yet Wild
Club Car
 
Join Date: Jun 2015
Location: Alabama
Posts: 25
Default 2008 Turf 2 starting then stopping

Whats up everyone I had to replace my delta shock assembly



so that wasn't to bad but after putting the cart back together it was acting funny. It would move but then randomly it would quit. Turning the key on off and switching the tow run switch it might drive a few feet then stop again. I don't really know where to look to start diagnosing the problem. Any ideas?



Also this rig is set up with 8 6 volt batteries, that is what other turf 2's have?

thoma015 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 06-29-2015, 11:03 PM   #2
DS Drivers Club Founder
 
CCFanatic's Avatar
Club Car
 
Join Date: Jul 2013
Location: Upstate NY
Posts: 3,408
Default Re: 2008 Turf 2 starting then stopping

Those are some old Trojans
CCFanatic is offline   Reply With Quote
Unread 06-30-2015, 12:39 AM   #3
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,966
Default Re: 2008 Turf 2 starting then stopping

Check the wires on the back of the key switch to make sure they're tight.
TahoeDawgZ71 is offline   Reply With Quote
Unread 06-30-2015, 12:40 AM   #4
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,966
Default Re: 2008 Turf 2 starting then stopping

All vehicles with the IQ Plus system have 8 6 volt batteries
TahoeDawgZ71 is offline   Reply With Quote
Unread 06-30-2015, 11:50 PM   #5
Not Yet Wild
Club Car
 
Join Date: Jun 2015
Location: Alabama
Posts: 25
Default Re: 2008 Turf 2 starting then stopping-and other problems

I think it may be the solenoid going bad so Im replacing it with a new one this weekend.

As im working on fixing things that dont work i cant seem to figure out what this foot switch is. It reminds me of a old bright light dimmer switch but there is also a horn tucked under the dash. I didnt have a multi-meter but i ordered from amazon so it should be here this weekend. In the mean time i was going to see if anyone had any thoughts on what this is normally used for any why it might not be working?



thoma015 is offline   Reply With Quote
Unread 07-01-2015, 12:17 AM   #6
DS Drivers Club Founder
 
CCFanatic's Avatar
Club Car
 
Join Date: Jul 2013
Location: Upstate NY
Posts: 3,408
Default Re: 2008 Turf 2 starting then stopping

That'd be the horn button

Try putting 12v directly to the horn. If that works, start tracing the wires from the switch and the power source
CCFanatic is offline   Reply With Quote
Unread 07-01-2015, 08:48 PM   #7
Gone Wild
 
jjance's Avatar
Club Car
 
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
Default Re: 2008 Turf 2 starting then stopping

I agree with the solenoid being bad.
jjance is offline   Reply With Quote
Unread 07-06-2015, 08:47 PM   #8
Not Yet Wild
Club Car
 
Join Date: Jun 2015
Location: Alabama
Posts: 25
Default Re: 2008 Turf 2 starting then stopping

Still no dice. Replaced the solenoid today and it did the exact same thing as with the old solenoid. Any other advice to what may be causing the problem?
thoma015 is offline   Reply With Quote
Unread 07-06-2015, 09:04 PM   #9
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,966
Default Re: 2008 Turf 2 starting then stopping

Did you check the wires on the back of the keyswitch?
TahoeDawgZ71 is offline   Reply With Quote
Unread 07-06-2015, 09:23 PM   #10
Not Yet Wild
Club Car
 
Join Date: Jun 2015
Location: Alabama
Posts: 25
Default Re: 2008 Turf 2 starting then stopping

Quote:
Originally Posted by TahoeDawgZ71 View Post
Did you check the wires on the back of the keyswitch?
I did...the key clicks when you turn it to on as well, but he main solenoid doesn't click when i push the peddle. Like it said it will go for a min or so then stop. Then after a little while of sitting do the same thing.
thoma015 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
96ezgo txt keeps starting and stopping Electric EZGO
1980 2cycle clunking when starting and stopping Gas EZGO
2008 Club Car Carryall Turf 1 Members Rides
84 ezgo starting and stopping Gas EZGO
Club Car ds intermittent stopping/starting Electric Club Car


All times are GMT -5. The time now is 05:28 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.