|
|
|||||||
| Electric Club Car Electric DS, and Precedent golf cars |
  |
|
|
Thread Tools | Display Modes |
07-03-2015, 11:56 AM
|
#1 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
99 club car quit running and won't charge
I have a 99 club car ds 48 volt. I got the car a few weeks ago and have been using it since. Last night I charged it for a bit and went for a trip around the campground. I made it about 100 yards and stopped to talk for a few when I went to pull off it kinda jumped a few times then just quit doing anything. Got it back and tried plugging in the charger and it won't kick on or anything. I am new at golf carts. Just looking for some help on which way to go about fixing it. I did check the batteries and have 51 volts across the pack.
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
07-03-2015, 12:54 PM
|
#2 |
|
Not Yet Wild
Join Date: Sep 2014
Posts: 2
|
Re: 99 club car quit running and won't charge
Check battery voltage and connections. Sounds like there's an open in wiring or batteries some where. The charger needs to sense so much voltage before it will turn on.
|
|
|
|
|
07-03-2015, 12:54 PM
|
#3 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
I just checked each Side of the sylnoid and have 51 volts on each side of it also. Is my controller bad?
|
|
|
|
|
07-03-2015, 12:56 PM
|
#4 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
I cleaned all terminals 2 weeks ago and tighten everything up. And I have 51 v across all battery's and at the sylnoid
|
|
|
|
|
07-03-2015, 01:16 PM
|
#5 |
|
Old Sky Soldier
 Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 99 club car quit running and won't charge
Put cart in tow, take neg then pos battery cables loose. Pull rear access cover and check the coil on the driver side solenoid, if it is broke or loose that could be the problem. Check for loose or bad connections while you are back there.
|
|
|
|
|
07-03-2015, 01:26 PM
|
#6 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
Everything looked good back there that was the sylnoid I was talking about have voltage on both sides. I also took the cables loose trying to reset the controller but no luck. I'm thinking the controller is shot 😒
|
|
|
|
|
07-03-2015, 01:44 PM
|
#7 |
|
Gone Wild
Join Date: Apr 2014
Location: Oregon City, Or
Posts: 1,977
|
Re: 99 club car quit running and won't charge
Since the charger will not try to start, have you tried a OBC re-set?
. |
|
|
|
|
07-03-2015, 02:28 PM
|
#8 |
|
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 99 club car quit running and won't charge
Are you getting a click on both solenoids?
|
|
|
|
|
07-03-2015, 03:48 PM
|
#9 |
|
Not Yet Wild
Join Date: Jul 2015
Posts: 12
|
Re: 99 club car quit running and won't charge
I did try the obc reset I found the instructions on here. I only see one solenoid under the rear cover and I can not here a click on it but I have checked voltage on both sides and have the same coming thur it
|
|
|
|
|
07-03-2015, 04:59 PM
|
#10 |
|
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 99 club car quit running and won't charge
You must have a series cart. Forward reverse lever instead of rocker switch. Should have ask that to start with.
 |
|
|
|
|
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Club Car just quit - batteries dead & won't charge | Electric Club Car | |||
| Club Bar just quit - batteries dead & won't charge | Electric Club Car | |||
| 03 Club Car stopped running and it will not charge please help! | Electric Club Car | |||
| 94 club car quit running- again | Electric Club Car | |||
| 2000 48V Club Car quit while running | Electric Club Car | |||
Linear Mode
