lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-21-2015, 04:15 PM   #1
Not Yet Wild
 
Join Date: Jul 2015
Posts: 3
Default club car will not go

Checked solenoid. Two big posts checked ok. Two small terminals had no voltage. Unplugged power going to the thottle and checked volts on wires and had 48 volts. Plugged back in and cart still will not move forward or backward. Have a D & D progamable controller. Any suggestions?
Linda Lee is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-21-2015, 05:07 PM   #2
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,975
Default Re: club car will not go

Welcome to BGW.

Let's start with you cart serial number, above the go pedal. How did you test the big post? How did you check the small post? Where did you unplug wires for throttle ?
mrgolf is offline   Reply With Quote
Unread 07-21-2015, 09:16 PM   #3
Not Yet Wild
 
Join Date: Jul 2015
Posts: 3
Default Re: club car will not go

We unhooked wires from big posts. Checked across posts with OM meter. Had zero reading.
Unplugged two small wires and put Volt meter on 50 amps. Turned key on, put in forward, pressed trottle and had no voltage.Hooked wires back up to all posts and unplugged the two wires plugged at the throttle pedal. Put meter on 50 amps. Checked current across the two wires and had 48 volts. Plugged wires back in turned key on, put in forward, pushed down trottle. Still will not go.
Linda Lee is offline   Reply With Quote
Unread 07-21-2015, 09:23 PM   #4
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,975
Default Re: club car will not go

Ok what year cart and what drive system. Serial number will give that information.

We can then look at wiring diagrams and see where the problem is.
mrgolf is offline   Reply With Quote
Unread 07-21-2015, 09:34 PM   #5
Not Yet Wild
 
Join Date: Jul 2015
Posts: 3
Default Re: club car will not go

Serial number PQ0631-658219

It is a 2006
Linda Lee is offline   Reply With Quote
Unread 07-21-2015, 09:52 PM   #6
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,975
Default Re: club car will not go

The reading across was the big post on the solenoid should show open when not activated and the resistor is off. If you connect jumper from main neg to one side of the small post and and main pos to the other it should click and the two big post should show closed or connected.

This will tell if the solenoid is good. Be sure the pos jumper go's to the small post with the ring around the diode.
mrgolf is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes



All times are GMT -5. The time now is 05:06 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.