|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-02-2015, 09:31 PM | #1 |
Not Yet Wild
Join Date: Jul 2015
Posts: 4
|
Removing 2007 Precedent Steering wheel.
How in the world do you remove these things to put a new one on? Any suggestions?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-02-2015, 09:36 PM | #2 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: Removing 2007 Precedent Steering wheel.
Loosen the nut to flush with top of shaft. Set on seat use knees to push up on stearing wheel while using a hammer and block of wood on the nut. Whack the hill out of it.
|
08-03-2015, 12:35 AM | #3 |
Gone Wild
Join Date: Jun 2014
Location: Green Valley, Az
Posts: 678
|
Re: Removing 2007 Precedent Steering wheel.
When that doesn't work cut all the plastic off until you get to the steel hub...use a good quality bearing splitter type puller and it will come right off.
|
08-03-2015, 02:16 PM | #4 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: Removing 2007 Precedent Steering wheel.
Just wiggle it off, that's the easiest.
|
08-03-2015, 04:38 PM | #5 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Removing 2007 Precedent Steering wheel.
Precedent steering wheels shouldn't be hard to remove. Remove the bolt and tighten it 4 or 5 threads by hand. Take a hammer and hit the head of the bolt directly in the center as if you were driving a nail. After the 2nd or 3rd hit, the wheel should jump off of the inner shaft and allow you to get it off.
|
08-03-2015, 09:35 PM | #6 |
Gone Wild
Join Date: Jun 2014
Location: Green Valley, Az
Posts: 678
|
Re: Removing 2007 Precedent Steering wheel.
There are always the tough ones...I did everything suggested...the sawsall turned out to be my best friend...I did cut the entire steering wheel off and then used a bearing splitter puller and when it came it made a loud pop and then it was over...finally.
|
08-03-2015, 09:47 PM | #7 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Removing 2007 Precedent Steering wheel.
Was this on a Precedent or a DS? They're different. A DS has lots of little small splines, a Precedent is on a hex shaped shaft, I've never seen one get stuck.
|
08-04-2015, 04:14 PM | #8 |
Gone Wild
Join Date: Jun 2014
Location: Green Valley, Az
Posts: 678
|
Re: Removing 2007 Precedent Steering wheel.
Your right it was a DS
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Removing a Precedent steering wheel! | Electric Club Car | |||
Removing the Steering Wheel | Electric Club Car | |||
removing steering wheel | Electric Club Car | |||
Removing G22 steering wheel | Gas Yamaha | |||
Removing Steering Wheel? | Gas Yamaha |