lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 09-04-2015, 10:00 AM   #1
scorpionking
Not Yet Wild
 
Join Date: Aug 2014
Posts: 20
Default power loss

2004.5 club car ds 48 v IQ I replaced the controller with a curtis 350 amp 2 months ago everything ran fine but now with fully charged batteries I have no acceleration and a loss of power after a minute where it will slow to a crawl?
scorpionking is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 09-04-2015, 10:40 AM   #2
scooterman
Gone Wild
 
scooterman's Avatar
Club Car
 
Join Date: Jan 2014
Location: Lafayette, Louisiana
Posts: 1,677
Default Re: power loss

Might try running the speed sensor test in the stickies, good place to start.

http://www.buggiesgonewild.com/elect...nsor-test.html
scooterman is offline   Reply With Quote
Old 09-04-2015, 10:53 AM   #3
scorpionking
Not Yet Wild
 
Join Date: Aug 2014
Posts: 20
Default Re: power loss

did the speed sensor test and that checks out about a month ago i did have a problem with my MCOR and did the 30 pedal push trick and that solved the problem now im wondering if thats the problem
scorpionking is offline   Reply With Quote
Old 09-04-2015, 12:13 PM   #4
scooterman
Gone Wild
 
scooterman's Avatar
Club Car
 
Join Date: Jan 2014
Location: Lafayette, Louisiana
Posts: 1,677
Default Re: power loss

Re-test that sensor and then look at the MCOR stickies next.
scooterman is offline   Reply With Quote
Old 09-04-2015, 02:02 PM   #5
scorpionking
Not Yet Wild
 
Join Date: Aug 2014
Posts: 20
Default Re: power loss

re checked the speed sensor all is well how ever I checked my batteries with a volt meter and Im only getting 49.5 for the pack and 7.6 individually always had over 50 and over 8 at full charge? another thing I did earlier this week was change my battery cables to the #4 I did them one at a time so no chance I rewired them wrong and I just found that my yellow battery light was disconnected plugged it back in and now light goes off and on while on charger as i said before I did have to do the mcor pedal pump 30-50 times but the last month its been running great until today... slower than usual acceleration then slowing to crawl...im lost as what to do next
scorpionking is offline   Reply With Quote
Old 09-04-2015, 05:43 PM   #6
TahoeDawgZ71
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
Default Re: power loss

Might need to check those batteries a little closer. You say you're getting 49.5 for the entire pack, but only 7.6 on each battery. 7.6 times 6 is not 49.5.... It's 45.6, which is DEAD
TahoeDawgZ71 is offline   Reply With Quote
Old 09-04-2015, 07:38 PM   #7
scorpionking
Not Yet Wild
 
Join Date: Aug 2014
Posts: 20
Default Re: power loss

Evidently it hasn't been taking a charge since I changed the cables I charge it every night as I drive it everyday the charger needle shows it charging and I just figured it was charging. Any ideas as to why they quit taking a charge when all I did was change cables?
scorpionking is offline   Reply With Quote
Old 09-04-2015, 08:22 PM   #8
glassk
Gone Wild
 
glassk's Avatar
Club Car
 
Join Date: Dec 2011
Location: Hampton, GA
Posts: 467
Default Re: power loss

Did the wire go back through the OBC, ??
glassk is offline   Reply With Quote
Old 09-04-2015, 08:28 PM   #9
scorpionking
Not Yet Wild
 
Join Date: Aug 2014
Posts: 20
Default Re: power loss

The negative wire for the pack did
scorpionking is offline   Reply With Quote
Old 09-04-2015, 09:46 PM   #10
teecro
Gone Wild
 
teecro's Avatar
Club Car
 
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,390
Default Re: power loss

Quote:
Originally Posted by scorpionking View Post
Evidently it hasn't been taking a charge since I changed the cables I charge it every night as I drive it everyday the charger needle shows it charging and I just figured it was charging. Any ideas as to why they quit taking a charge when all I did was change cables?
Did you perhaps drop or fail to connect the red wire that is coming from your charging receptacle to the main (+) connection of your batteries? This has happened before....
teecro is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G22 Power Loss Gas Yamaha
Loss of Power and Batteries Loss Charge Faster Electric EZGO
G16 loss of power Gas Yamaha
loss of power Electric EZGO
Loss of power Gas EZGO


All times are GMT -5. The time now is 04:44 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.