09-04-2015, 10:00 AM | #1 |
Not Yet Wild
Join Date: Aug 2014
Posts: 20
|
power loss
2004.5 club car ds 48 v IQ I replaced the controller with a curtis 350 amp 2 months ago everything ran fine but now with fully charged batteries I have no acceleration and a loss of power after a minute where it will slow to a crawl?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-04-2015, 10:40 AM | #2 |
Gone Wild
Join Date: Jan 2014
Location: Lafayette, Louisiana
Posts: 1,677
|
Re: power loss
Might try running the speed sensor test in the stickies, good place to start.
http://www.buggiesgonewild.com/elect...nsor-test.html |
09-04-2015, 10:53 AM | #3 |
Not Yet Wild
Join Date: Aug 2014
Posts: 20
|
Re: power loss
did the speed sensor test and that checks out about a month ago i did have a problem with my MCOR and did the 30 pedal push trick and that solved the problem now im wondering if thats the problem
|
09-04-2015, 12:13 PM | #4 |
Gone Wild
Join Date: Jan 2014
Location: Lafayette, Louisiana
Posts: 1,677
|
Re: power loss
Re-test that sensor and then look at the MCOR stickies next.
|
09-04-2015, 02:02 PM | #5 |
Not Yet Wild
Join Date: Aug 2014
Posts: 20
|
Re: power loss
re checked the speed sensor all is well how ever I checked my batteries with a volt meter and Im only getting 49.5 for the pack and 7.6 individually always had over 50 and over 8 at full charge? another thing I did earlier this week was change my battery cables to the #4 I did them one at a time so no chance I rewired them wrong and I just found that my yellow battery light was disconnected plugged it back in and now light goes off and on while on charger as i said before I did have to do the mcor pedal pump 30-50 times but the last month its been running great until today... slower than usual acceleration then slowing to crawl...im lost as what to do next
|
09-04-2015, 05:43 PM | #6 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: power loss
Might need to check those batteries a little closer. You say you're getting 49.5 for the entire pack, but only 7.6 on each battery. 7.6 times 6 is not 49.5.... It's 45.6, which is DEAD
|
09-04-2015, 07:38 PM | #7 |
Not Yet Wild
Join Date: Aug 2014
Posts: 20
|
Re: power loss
Evidently it hasn't been taking a charge since I changed the cables I charge it every night as I drive it everyday the charger needle shows it charging and I just figured it was charging. Any ideas as to why they quit taking a charge when all I did was change cables?
|
09-04-2015, 08:22 PM | #8 |
Gone Wild
Join Date: Dec 2011
Location: Hampton, GA
Posts: 467
|
Re: power loss
Did the wire go back through the OBC, ??
|
09-04-2015, 08:28 PM | #9 |
Not Yet Wild
Join Date: Aug 2014
Posts: 20
|
Re: power loss
The negative wire for the pack did
|
09-04-2015, 09:46 PM | #10 | |
Gone Wild
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,390
|
Re: power loss
Quote:
|
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
G22 Power Loss | Gas Yamaha | |||
Loss of Power and Batteries Loss Charge Faster | Electric EZGO | |||
G16 loss of power | Gas Yamaha | |||
loss of power | Electric EZGO | |||
Loss of power | Gas EZGO |