lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-14-2015, 06:52 PM   #1
Not Yet Wild
Club Car
 
Join Date: Dec 2013
Location: Melbourne, FL
Posts: 23
Default Club Car stuttering after deep water

I have a 1998 48 volt Club Car DS. After driving into some deep water and cart had to be pushed out because it stopped working, it ran again once out of said deep water. Cart drove normal for about another 5 minutes at which point it would stutter like power is being turned off and on and the more you push the pedal the faster the stutter. The floor board of the cart did go underwater about an inch, I don't believe the controller or solenoid got submerged but definitely got wet. I tried testing the controller with volt meter from B- and M- and I get 50 volts before pedal is pushed and drops only to 32 volts with pedal all the way down. The solenoid reads.03 volts on large post and small post read 50 volts before pedal is pushed and large post go to zero when pedal is pushed. What did I break?
src7253 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-19-2015, 02:06 PM   #2
Not Yet Wild
Club Car
 
Join Date: Dec 2013
Location: Melbourne, FL
Posts: 23
Default Re: Club Car stuttering after deep water

The motor was done!
src7253 is offline   Reply With Quote
Unread 09-19-2015, 04:07 PM   #3
Not Yet Wild
Club Car
 
Join Date: Sep 2015
Location: Englewood Fl & ZELIENOPLE Pa
Posts: 57
Default Re: Club Car stuttering after deep water

I have been around Electric Motors most of my working carrier.
A flooded motor is disassembled baked at about 135F for a couple of hours if Ball Bearings thet should be replaced
kendeiss is offline   Reply With Quote
Unread 09-19-2015, 09:09 PM   #4
Not Yet Wild
Club Car
 
Join Date: Dec 2013
Location: Melbourne, FL
Posts: 23
Default Re: Club Car stuttering after deep water

I have just installed new motor but still have the old one. I will try that out and see what happens.
src7253 is offline   Reply With Quote
Reply

Tags
controller, solenoid
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
How deep of water before I have cart failure? Electric Club Car
Resistor cart + deep water Electric EZGO
Deep Water Cart (anyone built one) Lifted Golf Carts
12v deep cycle optimas in club car Electric Club Car
Deep Water/ Clutch Slippage & Ignition Problems Big Block Talk!


All times are GMT -5. The time now is 11:23 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.