|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
09-16-2015, 05:05 AM | #1 |
Not Yet Wild
Join Date: Sep 2015
Location: Florida
Posts: 19
|
2011 Precedent electric Club Car Heditates
My 2011 Precedent Club Car has been checked and all battery posts, voltages, connections chech good.the Club Car , was just purchased and the cart will not go on intermittent occasions. Softly pressing the accelerator , or pushing hard does not engage motor. cart runs good at 14 mph, when it works, slow acceleration cart is a bit jumpy or not as smooth as you expect from Club Car, where or what may I check to fix this issue if no cart movement when accelerator is pressed. All batteries check good, all battery cells check good, terminals clean . Water levels perfect,
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-16-2015, 05:37 AM | #2 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2011 Precedent electric Club Car Heditates
The MCOR can cause both of those symptoms.
Hesitation: With the key OFF, press the pedal down and up about 30 to 50 times. This will remove any surface oxidation on the MCOR resistance track that controls the throttle signal.Cart not starting: Remove the 2-pin connector from the MCOR and place a large "paper clip" on the harness connector in order to by-pass the pedal switch inside the MCOR.If the cart works fine after that, replace the MCOR. |
09-16-2015, 08:13 AM | #3 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2011 Precedent electric Club Car Heditates
The correct part for your repair is AM293001 - MCOR2 to MCOR4 conversion kit. We sell lots of them as it's a very common issue.
|
03-15-2016, 09:21 AM | #4 | |
Gone Wild
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,390
|
Re: 2011 Precedent electric Club Car Heditates
Quote:
If you just bought an 11 model chances are good that it still has the OE batteries and that they are not long for this world, and as you stated your voltage in another post 48.8 volts is all but dead or about 50 % discharged. Fully charged an rested battery pack should be north of 50.5 volts. You likely need new batteries and surely need to replace the MCOR from a series 2 to a 4 as commented... |
|
03-15-2016, 07:33 PM | #5 | |
Gone Wild
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
|
Re: 2011 Precedent electric Club Car Heditates
Quote:
|
|
03-16-2016, 06:28 AM | #6 |
Not Yet Wild
Join Date: Sep 2015
Location: Florida
Posts: 19
|
Re: 2011 Precedent electric Club Car Heditates
Okay if I may indulge you all again. my Precedent 2011 Ser.# PH1143 Batteries under fully charged reading of 48.4 volts and with two issues I wish to correct or improve,
you all say 48.4 volts 2011 original Trojan 8 volt batteries needs replacement, and I need a MCOR2 to MCOR4 conversion kit. will I need to anything to my tires , suspension, or brakes? One club car video says I need to read 48 volts minimum this is why I sort of question the usefulness of the batteries $$$$. what is the speed code that I need to have a dealer set with this new MCOR4 speed code 4 or speed code 5> |
03-16-2016, 07:11 AM | #7 | |
Gone Wild
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,390
|
Re: 2011 Precedent electric Club Car Heditates
Quote:
As to the MCOR2 to MCOR4 throttle conversion is something that my 2011 needed badly and I bought it nearly 2 years ago refurbed with crapped out batteries too.... The MCOR is built around a small cheap potentiometer and they wear out causing pedal issues like you described... Since you posted speed of 13.X MPH that tells us that you likely are set at speed code 3 which limits to 14 MPH... Speed Code 4 will get you closest to 20 MPH "WITH" good batteries, properly inflated tires and brakes that do not drag! Speed Code 5 will not work with your EXCEL based cart... YOU NEED TO START WITH GOOD BATTERIES AND BUILD FROM THERE !!! |
|
03-16-2016, 07:14 AM | #8 |
Gone Wild
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,390
|
Re: 2011 Precedent electric Club Car Heditates
NOTE: We also never take our batteries south of 48.4 volts either as this is where damage begins to set in that they never recover from....
|
03-16-2016, 04:01 PM | #9 |
Not Yet Wild
Join Date: Sep 2015
Location: Florida
Posts: 19
|
Re: 2011 Precedent electric Club Car Heditates
I will let you know how it turns out. I appreciate your patience ,,, all of you
|
03-16-2016, 06:04 PM | #10 |
Gone Wild
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,390
|
Re: 2011 Precedent electric Club Car Heditates
No problem.... While it sounds like a jaded rub we really do hear the "batteries are good" comment a lot and it more than like happened to us when we were new to this too... I myself was furious to have found weak batteries and a bad MCOR in a completely refurbished cart I purchased from a very large shop with an Internet presence.
|
Tags |
precedent elect hesitates |
|
|
Similar Threads | ||||
Thread | Forum | |||
more speed for 2011 electric club car. | Electric Club Car | |||
2011 club car precedent 48v | Golf Carts and Parts | |||
2011 club car precedent gas add led lights | Gas Club Car | |||
2011 club car precedent gas backfiring | Gas Club Car | |||
2009-2011 Electric Precedent Maintenance and Service Manual | Electric Club Car |