lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-23-2015, 10:56 PM   #11
Not Yet Wild
Club Car
 
Join Date: Sep 2015
Location: Albuquerque NM
Posts: 67
Default Re: Newb needs help again!!

It worked fine before removing the body last night, then today, nothing. It's very frustrating but I appreciate your help!
Kmart06 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-23-2015, 11:34 PM   #12
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,030
Default Re: Newb needs help again!!

while you wait, do the wire & cable test give all of them a wiggle and a tug
then trace them , make sure none are pinched on frame
crash test dummy is online now   Reply With Quote
Unread 09-23-2015, 11:36 PM   #13
Not Yet Wild
Club Car
 
Join Date: Sep 2015
Location: Albuquerque NM
Posts: 67
Default Re: Newb needs help again!!

Ok, I'll run through them.
Kmart06 is offline   Reply With Quote
Unread 09-23-2015, 11:56 PM   #14
Not Yet Wild
Club Car
 
Join Date: Sep 2015
Location: Albuquerque NM
Posts: 67
Default Re: Newb needs help again!!

Everything looks good wire wise.
Kmart06 is offline   Reply With Quote
Unread 09-24-2015, 07:30 AM   #15
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,575
Default Re: Newb needs help again!!

What wires did You have to disconnect (it will help narrow down the possibilities)?
Sergio is online now   Reply With Quote
Unread 09-24-2015, 02:35 PM   #16
Not Yet Wild
Club Car
 
Join Date: Sep 2015
Location: Albuquerque NM
Posts: 67
Default Re: Newb needs help again!!

The f/r switch and the charging port. I unhooked the three wire harnesses on the back of the charging port and the yellow fuse
Kmart06 is offline   Reply With Quote
Unread 09-24-2015, 06:54 PM   #17
Not Yet Wild
Club Car
 
Join Date: Sep 2015
Location: Albuquerque NM
Posts: 67
Default Re: Newb needs help again!!

Just checked the battery voltage again after being on the charger overnight and there is 48.7 Volts from the series.
Kmart06 is offline   Reply With Quote
Unread 09-24-2015, 07:03 PM   #18
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,575
Default Re: Newb needs help again!!

That is pretty low...

Set You meter to 20vDC and measure each individual battery.

If the lowest one is the one where the pack positive cable is connected to, make sure the charger receptacle positive wire is also connected to that same battery post.
Sergio is online now   Reply With Quote
Unread 09-24-2015, 07:21 PM   #19
Not Yet Wild
Club Car
 
Join Date: Sep 2015
Location: Albuquerque NM
Posts: 67
Default Re: Newb needs help again!!

Three batteries are 12.6, one is 10.6. The one with 10.6 has the negative going to the controller. The positive from the charging port is connected to the battery that has the positive going to the controller, it has 12.6 V. Are you saying to put the battery with 10.6 V in place of the one that has the positive lead going to the controller?
Kmart06 is offline   Reply With Quote
Unread 09-24-2015, 07:27 PM   #20
Gone Wild
 
thetoddjohnson's Avatar
Mixed Breed
 
Join Date: Jun 2013
Location: North Carolina
Posts: 508
Default Re: Newb needs help again!!

No, Sergio wants to make sure that you are charging all the batteries. He was pointing out that the positive end of the bank might not be getting charged. It sounds like he might be on to it but the problem may be that you aren't charging the last battery on the other end.

TJ
thetoddjohnson is online now   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes



All times are GMT -5. The time now is 04:01 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.