lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-15-2015, 08:14 AM   #31
Not Yet Wild
 
Join Date: Oct 2015
Posts: 25
Default Re: 2002 Club Car DS just stopped after installing 2 gauge wires

This is the box I am referring to.
Attached Images
File Type: jpg MCOR.jpg (126.6 KB, 0 views)
seeyalatergator is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 10-15-2015, 09:07 AM   #32
Not Yet Wild
 
Join Date: Oct 2015
Posts: 25
Default Re: 2002 Club Car DS just stopped after installing 2 gauge wires

I read on another post about putting a paper clip in the wiring harness side of the two hole connector to the MCOR to test. Since I have pulled the end off mine, can I just join the blue wire and the green wire temporarily to see if the cart will run and therefore tell me if I need to buy the MCOR or try to fix the switch inside?
seeyalatergator is offline   Reply With Quote
Unread 10-15-2015, 02:58 PM   #33
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,582
Default Re: 2002 Club Car DS just stopped after installing 2 gauge wires

Yes, You can just connect the Green and the Blue wire together to by-pass that switch.

You can also run like that until You get the MCOR replaced, just make sure you turn the Key switch OFF when parked.
Sergio is online now   Reply With Quote
Unread 10-15-2015, 07:24 PM   #34
Not Yet Wild
 
Join Date: Oct 2015
Posts: 25
Default Re: 2002 Club Car DS just stopped after installing 2 gauge wires

Ok. I jumped the two wires and it worked. Tell me again what this bypasses?
seeyalatergator is offline   Reply With Quote
Unread 10-17-2015, 09:54 AM   #35
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,582
Default Re: 2002 Club Car DS just stopped after installing 2 gauge wires

There is series of safety "interlocks" that must be closed/engaged before the controller will activate the solenoid.
Tow/Run on Run.
Key Switch ON.
FNR on Forward or Reverse.
Pedal microswitch closed.
MCOR Throttle signal more than 5% (not exactly sure on the minimum percentage).
With the pedal switch by-passed and all of the other interlocks ON, there is a small possibility of a signal fluctuation in the MCOR resistance track could cause the cart to move by itself.

It is very unlikely to cause it to move when you turn the key ON since too much pedal signal when the key is turned ON would trigger a HPD fault and the cart would not move.

So you should replace the MCOR, but that is how that switch plays in the entire safety system.

Edit:
I am obviously not paying much attention this morning, You have a Series cart not a Sepex.
In this case the HPD fault would not protect you from a throttle signal issue accidentally causing movement at Key ON.
Make sure the key is always OFF when you are stopped and your foot is not on the brake if you use the cart with the by-pass in place.

Last edited by Sergio; 10-17-2015 at 10:06 AM.. Reason: Gave information for the wrong driving system
Sergio is online now   Reply With Quote
Unread 10-19-2015, 12:04 PM   #36
Not Yet Wild
 
Join Date: Oct 2015
Posts: 25
Default Re: 2002 Club Car DS just stopped after installing 2 gauge wires

Ok. Thanks Sergio and everyone. This has been a very helpful group and I will replace the MCOR with the updated kit. Thanks!
seeyalatergator is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
How to tell the gauge of my wires Electric EZGO
86 Ds with 1/0 gauge wires Electric Club Car
2002 Club Car 36V Stopped Dead Electric Club Car
New 4 Gauge Wires Electric EZGO
2 gauge wires.. Electric EZGO


All times are GMT -5. The time now is 09:42 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.