lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-15-2015, 08:36 PM   #1
Gone Wild
 
Join Date: Mar 2013
Posts: 495
Default Club car Precedent sat in the rain now won't run

Hello BGW friends. I have a 2006 Precedent. Was a 4 12 volt Cart. Now it is 6 8 volts. Cart sat out in the rain and I noticed the reverse buzzer started going off. I tried to get it to stop but the only way was turn off the run tow switch. Now the cart will not run at all and I have no idea what is going on. I checked a couple of fuses and they were fine. Any idea's where to look? Thank you
grandpa1 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 10-15-2015, 08:55 PM   #2
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,021
Default Re: Club car Precedent sat in the rain now won't run

check for moisture at f/r switch , use hair dryer if needed to dry it out
crash test dummy is online now   Reply With Quote
Unread 10-16-2015, 01:03 AM   #3
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,961
Default Re: Club car Precedent sat in the rain now won't run

The switch actually comes apart. Use a screwdriver to pop the switch out of the housing. Unplug the wires and take a good look at the base of the switch. You'll see two tabs that you can pry apart to open the switch. Open it up and dry it out and put it back together and it should work fine.
TahoeDawgZ71 is offline   Reply With Quote
Unread 10-16-2015, 06:11 AM   #4
Gone Wild
 
Join Date: Mar 2013
Posts: 495
Default Re: Club car Precedent sat in the rain now won't run

Ok I will ck that this morning. I have a hand held that plugs into the controller but it will not show anything because the controller is not powering up I am assuming. I will check the switch first .
grandpa1 is offline   Reply With Quote
Unread 10-16-2015, 11:54 AM   #5
Gone Wild
 
Join Date: Mar 2013
Posts: 495
Default Re: Club car Precedent sat in the rain now won't run

Switch is dry. No go. I have power to the switch and power going out when I put it in forward or reverse.
grandpa1 is offline   Reply With Quote
Unread 10-16-2015, 07:08 PM   #6
Gone Wild
 
Join Date: Mar 2013
Posts: 495
Default Re: Club car Precedent sat in the rain now won't run

Ok I guess I am on my own. I will keep tinkering with it.
grandpa1 is offline   Reply With Quote
Unread 10-16-2015, 07:33 PM   #7
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,975
Default Re: Club car Precedent sat in the rain now won't run

Could this be a case of the mcor not working?
mrgolf is offline   Reply With Quote
Unread 10-16-2015, 07:53 PM   #8
DS Drivers Club Founder
 
CCFanatic's Avatar
Club Car
 
Join Date: Jul 2013
Location: Upstate NY
Posts: 3,408
Default Re: Club car Precedent sat in the rain now won't run

I think it's something with the F-R switch and related wiring. Especially since the buzzer was on (moisture created a short). Grandpa, was there any water / moisture inside the housing the F-R toggle itself sits in?
CCFanatic is offline   Reply With Quote
Unread 10-16-2015, 08:29 PM   #9
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,021
Default Re: Club car Precedent sat in the rain now won't run

sorry i was out tonight, my girlfriends says sorry too

put cart in tow, then remove the main negative battery cable and let it sit a few
reconnect it and see if buzzer goes off , put cart in run , see if it goes
mcor is water tight but a possibility
crash test dummy is online now   Reply With Quote
Unread 10-16-2015, 09:52 PM   #10
Gone Wild
 
Join Date: Mar 2013
Posts: 495
Default Re: Club car Precedent sat in the rain now won't run

Dude ladies always come first. I will try that in the morning. Also I found no moisture at all on the f&r switch .
grandpa1 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Club Car DS rain enclosure w/doors Golf Carts and Parts
rain cover, club,ez go cars Golf Carts and Parts


All times are GMT -5. The time now is 11:49 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.