lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 11-28-2015, 10:16 PM   #1
Not Yet Wild
Club Car
 
Join Date: Sep 2010
Posts: 65
Default cart lunges full throttle in forward and reverse....

I have a 06 ds iq with alltrax dcx 500 controller and cart has recently just lurches to full throttle with pedal depressed..in forward and reverse....will peel out on gravel....seems to just want to run full tilt? any suggestions?[/
dracor is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-29-2015, 09:20 AM   #2
Gone Wild
 
jjance's Avatar
Club Car
 
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
Default Re: cart lunges full throttle in forward and reverse....

Check your throttle settings. Once I accidentally selected a 0 to 5k setting instead of 5k to 0 CC setting
jjance is offline   Reply With Quote
Unread 11-29-2015, 11:23 AM   #3
Not Yet Wild
Club Car
 
Join Date: Sep 2010
Posts: 65
Default Re: cart lunges full throttle in forward and reverse....

thanks, but I had installed controller 2 years ago and these symptoms just appeared out of no where.....
dracor is offline   Reply With Quote
Unread 11-29-2015, 11:33 AM   #4
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,564
Default Re: cart lunges full throttle in forward and reverse....

I have not heard of the Alltrax controllers loosing their configuration, but if it did, that could certainly cause an issue.

If You plug the software it will also allow you to monitor the throttle input percentage so You can see what is happening.

The only other thing to try is to remove the 3-pin connector from the MCOR to see if the MCOR is somehow causing the problem.
Sergio is online now   Reply With Quote
Unread 11-29-2015, 12:19 PM   #5
Not Yet Wild
Club Car
 
Join Date: Sep 2010
Posts: 65
Default Re: cart lunges full throttle in forward and reverse....

all points appear to faulty MCRO at this point???...according to installation for alltrax controllers speed sensor to stock motor remains disconnected..
dracor is offline   Reply With Quote
Unread 11-29-2015, 12:46 PM   #6
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,564
Default Re: cart lunges full throttle in forward and reverse....

It could also be an interface board, controller issue or short in the MCOR harness.

If You disconnect the 3-pin connector and the cart still goes full speed when You press the pedal and close the micro switch on the 2-pin connector, then the issue is not the MCOR.
Sergio is online now   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
cart goes full speed in reverse not forward Electric Club Car
83 ezgo full power in reverse, not so much in forward Gas EZGO
full forward to full reverse... a blown fuse? Electric golf carts
95 Club Car Won't Run Full Throttle Forward Electric Club Car
Full power in Reverse but very little going forward?? Gas EZGO


All times are GMT -5. The time now is 11:03 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.