lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 01-12-2016, 01:29 PM   #1
Not Yet Wild
 
Join Date: Aug 2011
Location: Wadesboro, NC
Posts: 47
Default Club Car not charging, wont go

Hello all. First time starting a thread here. Okay, here are the important information:
Club Car Precedent
Serial # PQ0540-557481

Cart has been sitting for a few months. Went to get it out and it was dead. Checked batteries and 2 were bad, so they were replaced. The other 2 tested good but low, so I slow charged them back to the good. Plugged in charger and nothing happened. Have a friend who has a club car as well, I got his charger and tested it to see if my charger was bad. His charger will not charge the cart either. Tested the battery pack and it has around 44 v. From my previous research this should be enough to turn on the charger, I would think it would be enough to at least drive it as well. So when I press the pedal I get the click at the pedal but no click at the solenoid. When the key is turned on the controller cycles through and shows green on the indicator light which means there is good voltage on the cart, I am correct. Help would be appreciated.
buggy1 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 01-12-2016, 02:12 PM   #2
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,584
Default Re: Club Car not charging, wont go

Quote:
When the key is turned on the controller cycles through and shows green on the indicator light which means there is good voltage on the cart, I am correct.
What controller do You have, an Alltrax? what model?

I would guess the 2 "weak" batteries are dead as soon as You put a load on them.

Since You just replaced the batteries, make sure You did not forget to connect the red wire from the charger receptacle to battery #1 positive post (pack positive).

If that wire is connected, does the relay click inside the charger when You plug the DC cord into the cart?
Sergio is online now   Reply With Quote
Unread 01-12-2016, 02:29 PM   #3
Not Yet Wild
 
Join Date: Aug 2011
Location: Wadesboro, NC
Posts: 47
Default Re: Club Car not charging, wont go

It is an Alltrax controller. I will have to get the Serial # for you. The 2 batteries that were replaced were the last 2 in the series.
buggy1 is offline   Reply With Quote
Unread 01-12-2016, 02:29 PM   #4
Not Yet Wild
 
Join Date: Aug 2011
Location: Wadesboro, NC
Posts: 47
Default Re: Club Car not charging, wont go

The charger does nothing. No click or anything.
buggy1 is offline   Reply With Quote
Unread 01-12-2016, 02:38 PM   #5
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,584
Default Re: Club Car not charging, wont go

Most likely the red wire from charger receptacle is not connected to pack positive, also check that the quick connect plug on the back of the OBC is not disconnected.

We do not need the Serial number from the controller, just the Model #.
Sergio is online now   Reply With Quote
Unread 01-12-2016, 02:48 PM   #6
Gone Wild
Club Car
 
Join Date: Sep 2012
Location: Alberta - Canada
Posts: 998
Default Re: Club Car not charging, wont go

Quote:
Most likely the red wire from charger receptacle is not connected to pack positive
When people replace their batteries, the red charger wire from the charging receptacle tends to drop down near the outside frame and is forgotten when the batteries are reconnected. Happens a LOT!
joesam is offline   Reply With Quote
Unread 01-12-2016, 03:04 PM   #7
Not Yet Wild
 
Join Date: Aug 2011
Location: Wadesboro, NC
Posts: 47
Default Re: Club Car not charging, wont go

Okay
Controller - Alltrax DCX3001Q w/Adpt. CCK-O
buggy1 is offline   Reply With Quote
Unread 01-12-2016, 03:05 PM   #8
Not Yet Wild
 
Join Date: Aug 2011
Location: Wadesboro, NC
Posts: 47
Default Re: Club Car not charging, wont go

Opps the adapt is CC5K-O
Sorry. Brain is faster than my fingers.
buggy1 is offline   Reply With Quote
Unread 01-12-2016, 03:09 PM   #9
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,982
Default Re: Club Car not charging, wont go

Not long ago someone had a problem like that, it seems the AC electric was not there for the charger.
mrgolf is offline   Reply With Quote
Unread 01-12-2016, 03:11 PM   #10
Not Yet Wild
 
Join Date: Aug 2011
Location: Wadesboro, NC
Posts: 47
Default Re: Club Car not charging, wont go

Just so I am on the same page here. I replaced the last 2 batteries in the pack. I switched the cart to tow and disconnected the 2 batteries to be replaced. I did not disconnect the first battery in the pack that has the charger wire you are referring to. Should I have done this?
buggy1 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Club car wont run Electric Club Car
Ezgo txt 36v powerwise charger wont stop charging Electric Club Car
EZGO94 model, charger wont begin charging Electric EZGO
93 gas club car wont run Gas Club Car
New to me 97 ds project, charger wont stop charging. Electric Club Car


All times are GMT -5. The time now is 12:17 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.