lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 01-24-2016, 11:38 AM   #1
Not Yet Wild
 
Join Date: Nov 2014
Posts: 2
Default 2002 CC with Alltrax DCX 500 fails to slow

The cart SN is AQ0224-155876 and has a D&D Motor. It will run OK for a few minutes then fail to barely able to move. The alltrax has a harness converter board to fit the cart harness. The batteries are good and the charger works. I used my controller pro software and the controller is set right but the throttle position will go from 100 to 13 %. I replaced the MCOR and it ran about 15 minutes normally and then went to hardly moving and no power. So far I can't find a harness issue. I don't believe the Alltrax uses a speed sensor all though the motor has one. Help!
frogproducts01 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 01-24-2016, 11:57 AM   #2
Gone Wild
 
jjance's Avatar
Club Car
 
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
Default Re: 2002 CC with Alltrax DCX 500 fails to slow

The throttle should go from 0% to 100%. Check setting and make sure Club Car 5k to 0 is selected. Is this a new install or has it been working? Don't forget to click SET afterwards. Some of these carts have resistors soldered inline. You might have to do a search to see if yours is one of them. And no it doesn't use the speed sensor but you can plug it in anyway.
jjance is offline   Reply With Quote
Unread 01-24-2016, 12:17 PM   #3
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,077
Default Re: 2002 CC with Alltrax DCX 500 fails to slow

Those converter boards had some issues late in production. Call Alltrax tech support and ask about the possibility of a converter board failure.
scottyb is offline   Reply With Quote
Unread 01-24-2016, 02:00 PM   #4
Not Yet Wild
 
Join Date: Nov 2014
Posts: 2
Default Re: 2002 CC with Alltrax DCX 500 fails to slow

The controller is set on CC 5K-0 3 wire on throttle. I measured it at the alltrax board on cart harness and it is getting the correct readings yet the controller pin side of the board are not. I will check on board from Alltrax- thanks
frogproducts01 is offline   Reply With Quote
Unread 01-24-2016, 04:27 PM   #5
Gone Wild
 
jjance's Avatar
Club Car
 
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
Default Re: 2002 CC with Alltrax DCX 500 fails to slow

Just for grins I would be tempted to try the 0-5k setting to see if something is wired backwards.
jjance is offline   Reply With Quote
Reply

Tags
cc slow speed
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Slow 2002 CC DS Electric Club Car
2002 G16 is slow and won't rev up Gas Yamaha
Have 2002 series txt, switching from 32v-48v and alltrax 485 and f&r switch Electric EZGO
2002 club car and alltrax 4855 charge problems Electric Club Car
2002 36v cc new batteries but very slow Electric Club Car


All times are GMT -5. The time now is 01:37 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.