lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 01-28-2016, 09:37 AM   #1
Not Yet Wild
Club Car
 
Join Date: Oct 2015
Location: Tempe, AZ
Posts: 3
Smile 2013 Club Car Carryall 2 48V Not charging

Hey everyone...

I have a 2013 Club Car Carryall 2, 48 volt electric. Complaint was that the vehicle wasn't charging... Checked it the other day and realized there wasn't a drop of water in the batteries (they were only 3 months old). So I refilled the batteries, tested them, found one of them to be bad, replaced it, and now I have what I believe to be 8 good batteries... But the charger won't kick on when I plug in the unit...

Just looking for where to go from here... Any help would be appreciated...
resonance411 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 01-28-2016, 10:25 AM   #2
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,110
Default Re: 2013 Club Car Carryall 2 48V Not charging

You need to charge each battery individually using a 12v charger (procedure below):

Jump starting a CC electric cart


All of the the batteries are likely to have permanent damage if the plates were exposed to air and/or allowed to fully discharge.

The next thing You need to find out is what caused the batteries to gas out, 3 months of regular use should not dry them out.
Sergio is offline   Reply With Quote
Unread 01-28-2016, 12:38 PM   #3
Not Yet Wild
Club Car
 
Join Date: Oct 2015
Location: Tempe, AZ
Posts: 3
Smile Re: 2013 Club Car Carryall 2 48V Not charging

I already went through and charged all the batteries individually... They are all reading at least 5.8v individually... Do I still need to use your method to jumpstart?

Thanks in advance... Really appreciate it...
resonance411 is offline   Reply With Quote
Unread 01-28-2016, 12:41 PM   #4
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,110
Default Re: 2013 Club Car Carryall 2 48V Not charging

Make sure You plugged the 10ga red wire from the charger receptacle back to the pack positive battery post.

If so, what is the voltage You get when You read it directly at the charger receptacle?
Sergio is offline   Reply With Quote
Unread 01-28-2016, 01:34 PM   #5
Not Yet Wild
Club Car
 
Join Date: Oct 2015
Location: Tempe, AZ
Posts: 3
Default Re: 2013 Club Car Carryall 2 48V Not charging

OMG... This is a horrible question... Where is the pack positive battery post?
resonance411 is offline   Reply With Quote
Unread 01-28-2016, 02:04 PM   #6
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,110
Default Re: 2013 Club Car Carryall 2 48V Not charging

The pack positive post is the same one that has a cable that goes to the Solenoid.

Make sure the 10ga red wire from the charger receptacle is connected to that same post.
Sergio is offline   Reply With Quote
Unread 10-03-2016, 05:52 AM   #7
Not Yet Wild
Club Car
 
Join Date: Oct 2016
Location: Myrtle Beach, SC
Posts: 6
Default Re: 2013 Club Car Carryall 2 48V Not charging

Bumping this thread as I have the same problem with 2 electric carryall 2 carts.
Oyster Bay Golf Links is offline   Reply With Quote
Unread 10-03-2016, 05:45 PM   #8
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,613
Default Re: 2013 Club Car Carryall 2 48V Not charging

These are "IQ Plus" carts so they may have an on-board charger. Is the charger mounted under the seat or is it external?
TahoeDawgZ71 is offline   Reply With Quote
Unread 10-04-2016, 07:05 AM   #9
Not Yet Wild
Club Car
 
Join Date: Oct 2016
Location: Myrtle Beach, SC
Posts: 6
Default Re: 2013 Club Car Carryall 2 48V Not charging

Both carts have separate chargers. We also have a club car ds with a separate charger. None of the chargers get excited on the carryall carts. I have tried the test in the sticky and also did the obc reset. Is the sense wire supposed to be a ground or carry voltage?
Oyster Bay Golf Links is offline   Reply With Quote
Unread 10-05-2016, 09:16 AM   #10
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,613
Default Re: 2013 Club Car Carryall 2 48V Not charging

It's a negative on the control lead.... Here's a troubleshooting guide...

Charging System Troubleshooting
TahoeDawgZ71 is offline   Reply With Quote
Reply

Tags
charger club car 48
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2013 drive efi charging problem Gas Yamaha
2013 Precedent charging problem... Electric Club Car
Club Car Carryall 2 : Charging starts and then stops! Electric Club Car
Club Car Carryall 232 Charging fault. Electric Club Car
97 Club Car 48 V Carryall 2 Charging problems Electric Club Car


All times are GMT -5. The time now is 03:51 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.