|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
01-28-2016, 10:37 AM | #1 |
Not Yet Wild
Join Date: Oct 2015
Location: Tempe, AZ
Posts: 3
|
2013 Club Car Carryall 2 48V Not charging
Hey everyone...
I have a 2013 Club Car Carryall 2, 48 volt electric. Complaint was that the vehicle wasn't charging... Checked it the other day and realized there wasn't a drop of water in the batteries (they were only 3 months old). So I refilled the batteries, tested them, found one of them to be bad, replaced it, and now I have what I believe to be 8 good batteries... But the charger won't kick on when I plug in the unit... Just looking for where to go from here... Any help would be appreciated... |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-28-2016, 11:25 AM | #2 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2013 Club Car Carryall 2 48V Not charging
You need to charge each battery individually using a 12v charger (procedure below):
http://www.buggiesgonewild.com/elect...ml#post1232804 All of the the batteries are likely to have permanent damage if the plates were exposed to air and/or allowed to fully discharge. The next thing You need to find out is what caused the batteries to gas out, 3 months of regular use should not dry them out. |
01-28-2016, 01:38 PM | #3 |
Not Yet Wild
Join Date: Oct 2015
Location: Tempe, AZ
Posts: 3
|
Re: 2013 Club Car Carryall 2 48V Not charging
I already went through and charged all the batteries individually... They are all reading at least 5.8v individually... Do I still need to use your method to jumpstart?
Thanks in advance... Really appreciate it... |
01-28-2016, 01:41 PM | #4 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2013 Club Car Carryall 2 48V Not charging
Make sure You plugged the 10ga red wire from the charger receptacle back to the pack positive battery post.
If so, what is the voltage You get when You read it directly at the charger receptacle? |
01-28-2016, 02:34 PM | #5 |
Not Yet Wild
Join Date: Oct 2015
Location: Tempe, AZ
Posts: 3
|
Re: 2013 Club Car Carryall 2 48V Not charging
OMG... This is a horrible question... Where is the pack positive battery post?
|
01-28-2016, 03:04 PM | #6 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: 2013 Club Car Carryall 2 48V Not charging
The pack positive post is the same one that has a cable that goes to the Solenoid.
Make sure the 10ga red wire from the charger receptacle is connected to that same post. |
10-03-2016, 05:52 AM | #7 |
Not Yet Wild
Join Date: Oct 2016
Location: Myrtle Beach, SC
Posts: 6
|
Re: 2013 Club Car Carryall 2 48V Not charging
Bumping this thread as I have the same problem with 2 electric carryall 2 carts.
|
10-03-2016, 05:45 PM | #8 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2013 Club Car Carryall 2 48V Not charging
These are "IQ Plus" carts so they may have an on-board charger. Is the charger mounted under the seat or is it external?
|
10-04-2016, 07:05 AM | #9 |
Not Yet Wild
Join Date: Oct 2016
Location: Myrtle Beach, SC
Posts: 6
|
Re: 2013 Club Car Carryall 2 48V Not charging
Both carts have separate chargers. We also have a club car ds with a separate charger. None of the chargers get excited on the carryall carts. I have tried the test in the sticky and also did the obc reset. Is the sense wire supposed to be a ground or carry voltage?
|
10-05-2016, 09:16 AM | #10 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2013 Club Car Carryall 2 48V Not charging
It's a negative on the control lead.... Here's a troubleshooting guide...
http://www.buggiesgonewild.com/elect...eshooting.html |
Tags |
charger club car 48 |
|
|
Similar Threads | ||||
Thread | Forum | |||
2013 drive efi charging problem | Gas Yamaha | |||
2013 Precedent charging problem... | Electric Club Car | |||
Club Car Carryall 2 : Charging starts and then stops! | Electric Club Car | |||
Club Car Carryall 232 Charging fault. | Electric Club Car | |||
97 Club Car 48 V Carryall 2 Charging problems | Electric Club Car |