lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 02-04-2016, 04:02 PM   #1
Not Yet Wild
 
Join Date: Jan 2016
Posts: 21
Angry 92 club car electric golf cart wont move

I purchased a 92 club car electric golf cart. It will not run. I found A bad microswitch and replaced it. Two of my batteries were bad so for diagnostic purposes only I put 12 volt on the cart. If I get it running I will put 2 6 v on it. It is a 36 v cart. I had to make cables because the person who had it lost them. The voltage on all of the batteries are what they are supposed to be at but it will not run. The reverse buzzes but it still doesnt move. The solenoid doesn't make any noises. I jacked cart up and jumped solenoid but still nothing happened. I looked up wiring schematic online and the blue wire was in the wrong place so I moved it. Help I hope I didn't waste my money.
sorsbytracy is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 02-04-2016, 04:22 PM   #2
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,028
Default Re: 92 club car electric golf cart wont move

ok take it one step at a time

is this the diagram you used ?

crash test dummy is online now   Reply With Quote
Unread 02-04-2016, 08:58 PM   #3
Not Yet Wild
 
Join Date: Jan 2016
Posts: 21
Default Re: 92 club car electric golf cart wont move

Thank you so much for your help. Yes that is the diagram I am using. Sorry it took so long to reply but I had to get baby to bed before I could go look.
sorsbytracy is offline   Reply With Quote
Unread 02-04-2016, 09:05 PM   #4
Not Yet Wild
 
Join Date: Jan 2016
Posts: 21
Default Re: 92 club car electric golf cart wont move

I have traced all of the wires and everything seems to be hooked up correctly. I had to reinstall the v glide because the previous owner had removed it but it shifts easily.
sorsbytracy is offline   Reply With Quote
Unread 02-04-2016, 09:44 PM   #5
Epb
Gone Wild
Club Car
 
Join Date: Mar 2012
Location: Katy, Tx
Posts: 1,019
Default Re: 92 club car electric golf cart wont move

Help I hope I didn't waste my money.[/QUOTE]
There is plenty of opportunity to make this cart yours! Think about the creation of your own cart. All issues can be resolved. It would be good to find a friends solenoid for the check.
Epb is offline   Reply With Quote
Unread 02-04-2016, 10:09 PM   #6
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,028
Default Re: 92 club car electric golf cart wont move

ok lets start with this solenoid not clicking
solenoid test
Quote:
Disconnect the negative battery cable from the battery. remove all wires, restorer , and diode from solenoid
test 1
Connect an volt meter, set on continuity, place on the two large terminal studs. The meter should indicate no continuity, Replace the solenoid if continuity is present.
test 2
Using jumper wires attach from main positive and main negative of battery pack to the two small solenoid studs, polarity is not important. You should hear a click as the solenoid engages, and the meter should indicate continuity on the two large terminals. Replace the solenoid if continuity is not present.
if solenoid clicks rapidly solenoid is bad
if solenoid is good then do these tests
do a continuity test on the key switch
if good then test the micro switch at the f/r switch
if good then test micro switch in the v-glide
then test continuity on all wires

you say you jumped solenoid and no go
check if f/r shiftier is making good contact
crash test dummy is online now   Reply With Quote
Unread 02-04-2016, 10:13 PM   #7
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,566
Default Re: 92 club car electric golf cart wont move

Quote:
I had to reinstall the v glide because the previous owner had removed it but it shifts easily
Since jumping the solenoid did not work, the issue is likely with the V-Glide.

Look at the detailed wiring of the V-Glide in the attached picture.

Make sure the 2 white cables are on the same post on the outside, and the wiper arm wire inside the V-GLide is also on that same post.

Attached Images
File Type: jpg V-Glide_36v.jpg (131.3 KB, 0 views)
Sergio is online now   Reply With Quote
Unread 02-04-2016, 10:20 PM   #8
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,028
Default Re: 92 club car electric golf cart wont move

Sergio is here
crash test dummy is online now   Reply With Quote
Unread 02-04-2016, 10:36 PM   #9
Epb
Gone Wild
Club Car
 
Join Date: Mar 2012
Location: Katy, Tx
Posts: 1,019
Default Re: 92 club car electric golf cart wont move

I have done my deed for the day. Got Sergio on board!
Epb is offline   Reply With Quote
Unread 02-05-2016, 05:34 PM   #10
Not Yet Wild
 
Join Date: Jan 2016
Posts: 21
Question Re: 92 club car electric golf cart wont move

Thanks everyone. I found a red wire from fuse receptacle to v glide instead of fuse receptacle to forward reverse switch. I am waiting on batteries to charge to see if this was the problem. Thanks a million. Maybe I'll get lucky and that was the only problem.
sorsbytracy is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
1992 ezgo marathon golf cart wont move Gas EZGO
Golf cart will start but wont move Gas EZGO
97 EZGO electric Cart - wont move Electric EZGO
golf cart wont move Electric EZGO
86 electric club car wont move Electric Club Car


All times are GMT -5. The time now is 01:01 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.