lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 04-22-2016, 11:47 AM   #1
Not Yet Wild
 
Join Date: Apr 2016
Posts: 1
Default 2003 48v Club Car w/Power Drive Charger not Charging

2003 Club Car, 48v, s# AQ0339-328014, bat 8 months old, water level good, POWER DRIVE charger.

hydrometer shows batteries need charged. Voltmeter shows 48 volts across all batteries.

PROBLEM Plug the charger in and charger comes on and reg 18v for 15 seconds, goes to 0, and back to18v like it should. However, only charges for about 4 minutes and turns off..... But hydrometer still shows batteries need charged.

Have tried to reset OBC by turn key off, rocker switch to off tow/run to tow, undoing neg cable, ...... tow run to run, rocker switch to rev, key to on, gas pedal to full speed..... (backup buzzer does not go off) but held pedal down for 10 minutes.. switch back to off, tow back to tow, rocker switch to off, reconnect neg cable.

Same problem

What do I try next.

Charging plug has a red wire going to first positive bat term, and a black and gray going to OBC

To bypass abc should I ground the black to the last neg battery terminal?
Is that my next step?

Thanks
SStra is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 04-22-2016, 11:55 AM   #2
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,035
Default Re: 2003 48v Club Car w/Power Drive Charger not Charging

to by pass OCB
DO AT YOUR OWN RISK.Ödo not attempt unless you are familiar with electricity and electronics!


disconnect the cartís gray wire at the fuse near the charger receptacle. Then using a jumper wire, connect the receptacle side of the fused connector to the cartís negative battery terminal. This will energize the chargerís 48V relay. If the charger doesnít come on, it could be bad connections, wiring or charger relay.

crash test dummy is offline   Reply With Quote
Reply

Tags
48v, club car 2003, not charging
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
FS: 48v Club Car power drive charger Golf Carts and Parts
CC 2003, 48v, Power-Drive 2 mod. 22110 NOT CHARGING Electric Club Car
Power Drive 3 Club Car Charger Help Electric Club Car
Power Drive 3 Charger not fully charging Electric Club Car
Club car power drive charger Electric Club Car


All times are GMT -5. The time now is 05:49 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.