lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 04-27-2016, 09:50 PM   #1
Not Yet Wild
 
TurkeyBuggy's Avatar
Club Car
 
Join Date: Dec 2009
Location: Mississippi
Posts: 33
Default Turkey Buggy wont go....

Ok... I have a problem. I have 50 VDC across batteries. My cart wont move. It's been acting up for a while now. Some times it works fine....but then the next day nothing happens. I have a older Club Car that I converted from 36volt to a 48VDC system. I have an alltrax axe4855 controller. I had a loose "A" wire on motor a while back. When I tighten the post it turned. I though I had pulled the brush off the armature. I pulled motor....original 1989...and I spun another post and broke one off. So I found a used motor...48V 10 hp... original was 36V 2 hp. Hook everything back up and same problem. Originally, I noticed I had noticed green blinks (I didn't count them though) when I turned switch on and pressed the peddle. My batteries were low...I hadn't had on charger in a while. I put the charger on and left over night. Have 51.7 VDC now. Turned key on (click), press peddle (hear the second click), but NO green led light now on Alltrax...its out (nothing). So I set up to check voltage across M- and B-. When I turn on key...I get about 25VDC. When I press the peddle, I hear the click and get 51.7 VDC. As I press down, the voltage stays the same. I have a 0-5K ohm peddle. I took loose from Alltrax... I have 0 ohms peddle up... 5K ohms with it down. OK...Do I have a bad controller? Can it be reset somehow? What do I need to check next?? any help would be appreciated!
TurkeyBuggy is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 04-27-2016, 09:53 PM   #2
Not Yet Wild
 
TurkeyBuggy's Avatar
Club Car
 
Join Date: Dec 2009
Location: Mississippi
Posts: 33
Unhappy Re: Turkey Buggy wont go....

OK... I have some how got this into the Electric EZGO section.... Out of place I guess
TurkeyBuggy is offline   Reply With Quote
Unread 04-27-2016, 10:06 PM   #3
Gone Wild
E-Z-GO
 
Join Date: Apr 2016
Location: Greenwood, SC
Posts: 1,291
Default Re: Turkey Buggy wont go....

I accidentally click the electric club car all the time when I meant ezgo. It can easily happen
Clemsoncartguy is offline   Reply With Quote
Unread 04-27-2016, 11:30 PM   #4
Moderator
 
rib33024's Avatar
E-Z-GO
 
Join Date: Apr 2009
Location: FT Lauderdale FL.
Posts: 13,161
Default Re: Turkey Buggy wont go....

Quote:
Originally Posted by TurkeyBuggy View Post
OK... I have some how got this into the Electric EZGO section.... Out of place I guess
Moved to Electric CC forum
rib33024 is offline   Reply With Quote
Unread 04-28-2016, 07:04 PM   #5
Not Yet Wild
 
TurkeyBuggy's Avatar
Club Car
 
Join Date: Dec 2009
Location: Mississippi
Posts: 33
Default Re: Turkey Buggy wont go....

Thanks for moving to the correct spot!
TurkeyBuggy is offline   Reply With Quote
Unread 04-28-2016, 09:24 PM   #6
Epb
Gone Wild
Club Car
 
Join Date: Mar 2012
Location: Katy, Tx
Posts: 1,019
Default Re: Turkey Buggy wont go....

A real simple check and it happened to me. Remove the connections off of the controller tabs 1 & 2 and clean them then re-try.
Epb is offline   Reply With Quote
Unread 04-28-2016, 10:37 PM   #7
Not Yet Wild
 
TurkeyBuggy's Avatar
Club Car
 
Join Date: Dec 2009
Location: Mississippi
Posts: 33
Default Re: Turkey Buggy wont go....

The key switch pin? Pin 1?? I have 48 VDC when I turn key on.... I'll check it again though! Thanks
Attached Images
File Type: png Snap 2016-04-28 at 21.33.23.png (86.0 KB, 0 views)
TurkeyBuggy is offline   Reply With Quote
Unread 04-29-2016, 08:28 AM   #8
Epb
Gone Wild
Club Car
 
Join Date: Mar 2012
Location: Katy, Tx
Posts: 1,019
Default Re: Turkey Buggy wont go....

I should have said all of them. I only use 1,2,3 on mine. I cleaned 1 & 2 and I had movement. Prior to that I had all the clicks and voltage and tight connections and that was my final check and worked.
You mentioned you were getting a green blink(s) it could just be the throttle input connections at controller. And the power tab 1 since you no longer get the green light. If after cleaning it doesn't work then it's the source. IMO. E
Epb is offline   Reply With Quote
Unread 04-29-2016, 06:25 PM   #9
Not Yet Wild
 
TurkeyBuggy's Avatar
Club Car
 
Join Date: Dec 2009
Location: Mississippi
Posts: 33
Default Re: Turkey Buggy wont go....

I'm going to disconnect and clean all of them in the morning. They look good...but you never know. Its weird, that I had a green LED before I charged the batteries. Now I have nothing. It's has been kinda strange...I could go get on cart and it wouldn't do anything. Come back later and it would act normal. Thanks for your input!
TurkeyBuggy is offline   Reply With Quote
Unread 04-30-2016, 07:50 AM   #10
Gone Wild
 
kgsc's Avatar
E-Z-GO
 
Join Date: Dec 2009
Location: Aiken, SC
Posts: 6,169
Default Re: Turkey Buggy wont go....

When you apply power you should get one green blink then solid green for the 0-5k throttle. If you're not getting that then check for power between pin 1 and b- on the controller. If it is 48 plus I suspect controller.
kgsc is offline   Reply With Quote
Reply

Tags
0-5000, alltrax, axe4855, contactor pulls in, m- & -b full voltage
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2005 bad boy buggy/ezgo wont now go in reverse? Electric EZGO
Turkey Hunters Hunting and Fishing
The Turkey Call Hunting and Fishing
My Buggy Wont Pull Fwd Or Bkwd?? Gas EZGO
Anyone Get Serious on Turkey Hunting Hunting and Fishing


All times are GMT -5. The time now is 08:40 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.