possible year model 36 v CC

spidey

what the cart doesn't have.....id # tag on passenger side, under cup holder or on frame rail behind the key switch.

what the cart does have....steering box(not a rack), 5 solenoids for resistors.

going to be a hunting cart if it is feasible to upgrade for a reasonable $.

thanks in advance for your help!

BGW

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

scottyb

I think the 5 solenoid was last produced in 1987 give or take a yr. Hard to tell an 87 from a 82. The only big difference being the motor spline count. This will determine upgrade motor availability. 10 tooth is good and 16 tooth is restricted. You might want to check that out by dropping the motor and counting.
All these resistor carts can be converted to solid state speed control and run with bigger motors on higher 48 volts to run with the big dogs. It's not cheap but, the results are great.

spidey

Thanks scottyb, will be giving you guy's a call soon, cart was a freebie, but rough, that's why it will be a good hunting cart I hope....can save some bucks with a rattle can camo paint job, I just want to be able to climb some hills.....have a 6" a-arm lift in the garage that happens to fit with a set of 20" all terrains i'd like to use.....maybe that will give you an idea of what I need providing I can count the splines on the rearend....thanks again

crash test dummy

5 solenoid club car ds cart was 80 to 88
before that the 75 to 79 club car caroche had the 5 solenoids
a photo would help

93yellowclubcar

He mentioned a steering box, so that should help too, what year did the rack and pinion come out?

scottyb

Oh yeah - I try to forget about the 3 pedal cockroache

spidey

my profile pic is a '90 Ds with rack and v-glide.....its a neighborhood/beach cart, my son and I built the bumpers, nerfs, rear seat and step bar.

the cart in question is the same body style but the body is considerably heavier than the '90 model. it has no other solenoids except the ones at the resistors and has a small box mounted close to where the v-glide mounts on the '90 model. we haven't found any microswitches for the solenoids either.

i'll post a pic in a few....thanks

crash test dummy

Club Car 84-Up is rack and pinion

scottyb

I can't take anything you post seriously. All I read is
jeep
jeep
jeep

93yellowclubcar

Microswitches are inside that small box.