lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 05-27-2016, 06:48 PM   #11
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,989
Default Re: Help.............Always "on/hot" Club Car Precedent

You unplugged all lighting? Including the grey Bullet connector behind the dash that ties the bucket harness into the vehicle wire harness?
TahoeDawgZ71 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 05-27-2016, 11:53 PM   #12
Gone Wild
 
Htownblue's Avatar
Club Car
 
Join Date: May 2015
Location: Houston
Posts: 339
Default Re: Help.............Always "on/hot" Club Car Precedent

I would check and see if you have a short from the harness including the key wires somewhere along the line. You might end up trading the line back to the controller and solenoid are and see if there perhaps is wiring error or maybe it's shorting somewhere in the line back. Just my two cents. Have you tested the voltage to the key assembly? Is it 50v or approximate on one wire and nothing on the other? If you have 50v on both female connectors to the key assembly, you know you've got a short in the line.

Test the voltage at the key assembly from the female connectors and post data. If both are zero I think I might know where to,start looking.
Htownblue is offline   Reply With Quote
Unread 06-01-2016, 06:23 PM   #13
Not Yet Wild
Club Car
 
Join Date: Sep 2009
Location: Aubrey, TX
Posts: 53
Default Re: Help.............Always "on/hot" Club Car Precedent

He said he disconnected everything.

The voltage to the switch at one time was around 12-13 volts. Then after everything was disconnected and reconnected he said it was 33.
markm is offline   Reply With Quote
Unread 06-02-2016, 02:01 PM   #14
Not Yet Wild
 
Join Date: Jun 2016
Posts: 1
Default Re: Help.............Always "on/hot" Club Car Precedent

Did you end up having any luck. I have a 12 Precedent doing the same thing. I have taken a perfectly good running cart and swapped ignition switch, controller, solenoid, fwd/rev switch, performed OBC reset just in case and still have same problem. Put all original parts back, completely unplugged harness that goes to ignition switch (etc) and cart will still operate with key off. The only way to keep cart from operating is to flip switch to "tow" mode.
K.King is offline   Reply With Quote
Unread 06-03-2016, 02:51 PM   #15
Not Yet Wild
Club Car
 
Join Date: Sep 2009
Location: Aubrey, TX
Posts: 53
Default Re: Help.............Always "on/hot" Club Car Precedent

Quote:
Originally Posted by K.King View Post
Did you end up having any luck. I have a 12 Precedent doing the same thing. I have taken a perfectly good running cart and swapped ignition switch, controller, solenoid, fwd/rev switch, performed OBC reset just in case and still have same problem. Put all original parts back, completely unplugged harness that goes to ignition switch (etc) and cart will still operate with key off. The only way to keep cart from operating is to flip switch to "tow" mode.
No luck yet and he has done just about everything you have done.
markm is offline   Reply With Quote
Unread 06-03-2016, 07:29 PM   #16
Gone Wild
 
Htownblue's Avatar
Club Car
 
Join Date: May 2015
Location: Houston
Posts: 339
Default Re: Help.............Always "on/hot" Club Car Precedent

Test the voltage reading at the female connectors that feed into the key switch. Have the cart in run if possible when doing so. I would recommend jacking up the cart and then testing the key switch voltages before having the key turned to on. If both are "hot" then you have a short in the line. You will have to trace the line back using a wiring diagram to find out how both wires are "hot" when the key is "off".
Htownblue is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Looking for "How to Change Brake Cable", 2005 Precedent Gas Club Car
Club Car belt/clutch won't "change", as stuck in "low" gear Gas Club Car
Why "Carbon Fiber" "Wood grain" and Diamond Plated? Gas EZGO
"slow" Precedent "need Speed" Gas Club Car
will 8" wheels work w/Precedent, w/6" Jakes lift, Lifted Golf Carts


All times are GMT -5. The time now is 03:23 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.