lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-24-2016, 09:27 AM   #1
Not Yet Wild
 
Join Date: Dec 2013
Posts: 22
Default Flooded carryall 6

My 1999 carryall went under during the flood last month in Louisiana. I had backed it up on a ramp and managed to keep the motor and most of the cart dry, but the charger and some of the electronics under the seat sat in water about a day. The charger had about 4" of water as well as the other electrical parts under the seat. When the water went down, I drove it around a few days, but it wouldn't charge. I bought a new charger and it charged up, but now when I put it in gear it goes without touching the accelerator pedal. Forward and reverse!!!!!! Any ideas??? Any help greatly appreciated! Thanks, JD
JD57 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-24-2016, 09:30 AM   #2
Gone Wild
Yamaha
 
Join Date: May 2012
Location: Rio Verde, Az
Posts: 2,512
Default Re: Flooded carryall 6

You will probably have to replace all of the switches that were under water. Start with the ones in the pedal. I would also have the motor serviced if it was under water. The brush holders will rust and keep the brushes from sliding properly. Disassemble and clean it. You probably also have water in the rear end. Change the rear end oil.
Volt_Ampere is offline   Reply With Quote
Unread 09-29-2016, 05:39 PM   #3
Not Yet Wild
 
Join Date: Dec 2013
Posts: 22
Default Re: Flooded carryall 6

I had backed it up on a ramp. The motor didn't go under. I put a new charger on it and charged it up and it wouldn't move. I unplugged a 30 amp fuse from the charger to the cart and then it would lurch forward or reverse when I shifted into gear. If I plugged the fuse back in, it wouldn't move, but it would charge...........? Not sure what to change next! It will go but BARELY!!!!!! Bout 1 MPH....... :(
JD57 is offline   Reply With Quote
Unread 09-29-2016, 05:41 PM   #4
Not Yet Wild
 
Join Date: Dec 2013
Posts: 22
Default Re: Flooded carryall 6

Where would be a good place to order parts from? Any sites have exploded views? I don't know what most of the parts are called......:)
JD57 is offline   Reply With Quote
Unread 10-02-2016, 09:37 PM   #5
Member #16,745
 
jakesnake27's Avatar
Club Car
 
Join Date: Aug 2009
Location: Missouri
Posts: 8,706
Default Re: Flooded carryall 6

Quote:
Originally Posted by JD57 View Post
Where would be a good place to order parts from? Any sites have exploded views? I don't know what most of the parts are called......:)
David at Revolution Golf Cars. He should be able to get you everything you need.
jakesnake27 is offline   Reply With Quote
Unread 10-07-2016, 05:44 AM   #6
Not Yet Wild
 
Join Date: Dec 2013
Posts: 22
Default Re: Flooded carryall 6

So far a new charger and new solenoid. Still doing the same thing. :(
JD57 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G29 flooded Electric Yamaha
Flooded G22 Gas Yamaha
Options for flooded G1 Electric Yamaha
Flooded vs AGM vs Gel batteries? Electric EZGO
Flooded vs AGM vs Gel Batteries Electric Club Car


All times are GMT -5. The time now is 11:18 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2016, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.