lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-24-2016, 05:54 PM   #1
Not Yet Wild
 
Join Date: Jun 2012
Posts: 21
Default 96 Carryall, no reverse.

After my motor controller burned up, scorching all the wires on it, I installed a new motor controller and repaired the wires and I just installed a new MCOR conversion kit.

Now it runs fine in forward but no reverse. When I put it in reverse and hit the accelerator the solenoid clicks just like it does when I put it in forward and hit the pedal.

What is the first thing I should check?
tallyho is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-24-2016, 08:24 PM   #2
Gone Wild
 
glassk's Avatar
Club Car
 
Join Date: Dec 2011
Location: Hampton, GA
Posts: 433
Default Re: 96 Carryall, no reverse.

If it's a series' cart, the reverse switch contacts,...
glassk is offline   Reply With Quote
Unread 09-24-2016, 08:41 PM   #3
Not Yet Wild
 
Join Date: Jun 2012
Posts: 21
Default Re: 96 Carryall, no reverse.

Thank you. I will check them first tomorrow. I was thinking that they would be ok since the solenoid clicks when I put it in reverse but I will be sure to check them.
tallyho is offline   Reply With Quote
Unread 09-25-2016, 08:59 PM   #4
Not Yet Wild
 
Join Date: Jun 2012
Posts: 21
Default Re: 96 Carryall, no reverse.

I got my Carryall working today. I had downloaded a manual and done every test they had for electrical components and they all checked out fine.

Puzzled, I started over from scratch with everything I did to my cart from the time it broke. First I had gotten a motor controller which was slightly different from the one I had so I went to another web site for instruction on installing it.

Hooking it up was fairly simple as I took wires off the old one, one by one, repaired them and put them on the corresponding terminals on the new controller. The wires that went to terminals 2 and 3 were completely burned off so I had to repair them and the web site said it did not matter which of these wires went on #2 or #3 terminal so after repairing them i just pushed them on either terminal.

This was the problem. Bad advice on that web site. I tried reversing these 2 wires and everything works now.

I won't go back to that web site for instructions again.
tallyho is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
1989 Club Car Carryall No reverse Gas Club Car
No forward or reverse Carryall 05 electric Electric Club Car
97 Carryall clutch issue - bangs into reverse Gas Club Car
clubcar carryall grinding in reverse Gas Club Car
My Carryall 272 will not go in reverse. Gas Club Car


All times are GMT -5. The time now is 01:28 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.