lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 04-22-2017, 08:19 AM   #1
Not Yet Wild
 
Join Date: Feb 2017
Posts: 9
Default Alltrax SR 48500 CC DS will not move

1998 CC DS new SR48500 and 400 amp solenoid installed. Now cart will not move.. Main Contactor clicks when throttle depressed but no Movement F/R. Rechecked all connections per alltrax wiring diagram. A #20 purple , red ,and #12 black wire came off B-on old control so I reinstalled them on new control on B-with #6 black wire from battery pack. All other wires are shown on schematic and verified to be connected properly.. Any Help appreciated where to go next?

wiring print I'm using is SR to Club Car DS 1995 to present Alltrax DOC110-037 Thanks for any help
halftrack is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 04-22-2017, 08:27 AM   #2
Not Yet Wild
 
Join Date: Feb 2017
Posts: 9
Default Re: Alltrax SR 48500 CC DS will not move

This is the print I am using as a reference http://r.search.yahoo.com/_ylt=A0LEVjqfWPtYylIArignnIlQ;_ylu=X3oDMTByOHZyb21 tBGNvbG8DYmYxBHBvcwMxBHZ0aWQDBHNlYwNzcg--/RV=2/RE=1492896032/RO=10/RU=http%3a%2f%2fwww.alltraxinc.com%2ffiles%2fDOC11 0-037-A_DWG-SR-CLUB-CAR-DS-WIRE-DIA.pdf/RK=0/RS=KZhAbsqGQNq.ll8WbU_OImK.xaM-[/URL]
halftrack is offline   Reply With Quote
Unread 04-22-2017, 09:42 AM   #3
go to cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 68,346
Default Re: Alltrax SR 48500 CC DS will not move

Your link not working for me I assume you are using the SR manual diagram page 17 - what are the LED indications and fault codes if any ( see page 24 for SR LED blink codes)
Attached Images
File Type: jpg SR to CC DS with OBC stud kit.JPG (252.6 KB, 0 views)
scottyb is offline   Reply With Quote
Unread 04-22-2017, 10:59 AM   #4
Not Yet Wild
 
Join Date: Feb 2017
Posts: 9
Default Re: Alltrax SR 48500 CC DS will not move

Hi again I get 1 green blink and then steady green as throttle is depressed. Also I checked voltage on main contactor. I get 52V on + terminal and 52V on -terminal with switch off or on throttle depressed or full up contactor clickes but no change in voltage.. Also I have 52V on motor at all terminals A1 A2 S1 S2with switch on or off. Going back to garage to check wiring on main contactor for resistor and diode with new wiring print out
halftrack is offline   Reply With Quote
Unread 04-22-2017, 11:36 AM   #5
go to cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 68,346
Default Re: Alltrax SR 48500 CC DS will not move

Quote:
Originally Posted by halftrack View Post
Hi again I get 1 green blink and then steady green as throttle is depressed. Also I checked voltage on main contactor. I get 52V on + terminal and 52V on -terminal with switch off or on throttle depressed or full up contactor clickes but no change in voltage.. Also I have 52V on motor at all terminals A1 A2 S1 S2with switch on or off. Going back to garage to check wiring on main contactor for resistor and diode with new wiring print out
Here is the problem, the controller throttle is set for 0-5k as you will see in the blink codes you read in the back of your owners install manual.
Proper throttle setting for 98CC is 5k-0 3 wire commonly known as MCOR - that is correct even if you have a 5k-0 V-glide, the 3 wire signal is the same.

Change the setting and you will likely be okay
scottyb is offline   Reply With Quote
Unread 04-23-2017, 11:25 AM   #6
Not Yet Wild
 
Join Date: Feb 2017
Posts: 9
Default Re: Alltrax SR 48500 CC DS will not move

Downloaded alltrax toolkit to laptop plugged in USB cable and viewed controller settings it was set to 0-5K two wire.. as there was no option for 5K-0 3wire. I just selected Club Car option and saved change. Now it runs fwd and rev. The only thing is I wish it had more power uphill..the speed increase is small.. Is the only option now get an after market (Admiral) or rebuilt motor (PQ)? Just looking for advice and thanks for the help this far..
halftrack is offline   Reply With Quote
Unread 04-23-2017, 11:38 AM   #7
I've always been crazy
 
NCPW's Avatar
Club Car
 
Join Date: Sep 2015
Location: North Carolina
Posts: 2,525
Default Re: Alltrax SR 48500 CC DS will not move

For an increase in speed, I think a high speed motor is in your future.
NCPW is offline   Reply With Quote
Unread 04-23-2017, 12:34 PM   #8
Gone Wild
 
Aflyer's Avatar
Club Car
 
Join Date: Jul 2016
Location: Charlotte NC
Posts: 1,107
Default Re: Alltrax SR 48500 CC DS will not move

halftrack,
What were/are you getting for top speed before and after this upgrade?

Aflyer
Aflyer is offline   Reply With Quote
Unread 04-23-2017, 03:19 PM   #9
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 9,585
Default Re: Alltrax SR 48500 CC DS will not move

You'll need a different motor to let that Alltrax do it's thing. The factory motor isn't built for that kind of power.
TahoeDawgZ71 is online now   Reply With Quote
Unread 04-24-2017, 02:27 PM   #10
Not Yet Wild
 
Join Date: Feb 2017
Posts: 9
Default Re: Alltrax SR 48500 CC DS will not move

With cart running so slow uphill I bought a used motor Admiral MOT A1.. Picture sure looked good will see when she arrives. Cart has some 4GA wires at present and I am going to upgrade the rest with motor install. Thanks for the advice on this project. Budget is tight right now. Hope to lift it and get A/T tires this summer.
halftrack is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Alltrax SPM 48500 error code Electric EZGO
Alltrax xct 4800 or 48500 2010 ydre Electric Yamaha
New Alltrax bearcat 48500 iq Electric Club Car
Mounting a Alltrax 48500 in a EZGO Electric EZGO
Alltrax SPM-48500 New Golf Carts and Parts


All times are GMT -5. The time now is 07:05 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.