|
05-17-2017, 06:48 PM
|
#1 |
|
Not Yet Wild
Join Date: May 2017
Posts: 5
|
No Power
I have a 2000 Club Car DS 48 volt, bought it used as is. It has a power problem and barely goes on a flat plane, uphill it stops dead. I put new batteries in and did some troubleshooting on solenoid, but not sure where to go next. There is a second solenoid with a "resistor" on it that glows orange within about 30 seconds after I try to drive it. Any help on where I might go next to troubleshoot would be greatly appreciated.
|
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
05-17-2017, 06:53 PM
|
#2 |
|
Old Sky Soldier
 Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: No Power
The solenoid with the resistor Coil is not working. Hook both large cable on same side of that solenoid and you should have full speed.
|
|
|
|
|
05-17-2017, 07:02 PM
|
#3 |
|
Not Yet Wild
Join Date: May 2017
Posts: 5
|
Re: No Power
That's sounds easy enough to try, I'll give it a shot.
|
|
|
|
|
05-17-2017, 07:55 PM
|
#4 |
|
Not Yet Wild
Join Date: May 2017
Posts: 5
|
Re: No Power
Thanks mrgolf. That did it. Runs like crazy and right up hills with plenty of power.
|
|
|
|
|
05-17-2017, 08:07 PM
|
#5 |
|
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: No Power
You should also unplug the speed sensor 3-pin connector from the motor or you will have a very strong motor brake effect.
|
|
|
|
|
05-17-2017, 08:43 PM
|
#6 |
|
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: No Power
That solenoid could be good and the activation circurit not be working. You might want to check out that part.
|
|
|
|
|
05-18-2017, 02:16 PM
|
#7 |
|
Not Yet Wild
Join Date: May 2017
Posts: 5
|
Re: No Power
OK. sounds good on both suggestions. I'll check it out.
|
|
|
|
|
05-18-2017, 05:23 PM
|
#8 |
|
Not Yet Wild
Join Date: May 2017
Posts: 27
|
Re: No Power
I would start with solenoid that glows! Lol. There is obviously high resistance within the solenoid that indicated damage. Replace and go from there.
Sent from my SM-G930V using Tapatalk |
|
|
|
|
05-18-2017, 05:34 PM
|
#9 | |
|
Gone Wild
Join Date: Apr 2014
Location: Oregon City, Or
Posts: 1,977
|
Re: No Power
Quote:
. |
|
|
|
|
|
05-23-2017, 07:40 PM
|
#10 |
|
Not Yet Wild
Join Date: May 2017
Posts: 5
|
Re: No Power
I changed the solenoid and all is good. runs great. thanks again
|
|
|
|
 |
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| Full power in reverse, part power in forward | Electric EZGO | |||
| Ezgo dies under power then regains power | Electric EZGO | |||
| 2005 Precedent starts of powered, then loses power, reverse always power | Electric Club Car | |||
| Power Wise Charger worked after board replaced now back to no power | Electric EZGO | |||
| have power on ezgo buggy no power light | Electric EZGO | |||
Linear Mode
