lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-03-2017, 08:32 AM   #1
Not Yet Wild
 
Join Date: Dec 2009
Posts: 3
Default Modified CC DS won't move.

Sorry if this has been covered. I searched but didn't find anything.

I have a '02 CC DS that has been heavily modified. Lift kit, high torque motor with Altrax controller kit from BU, has run good for years. Yesterday the kids were on it and it just shut down with 75% battery left. So here is what it's doing. As you push on the go pedal, it engages the motor and moves about an inch and shuts off again. If you let up and hit it again immediately, nothing. Give it 5 seconds and push Go again, same thing, starts to move then shuts off.
I've tried moving the FNR switch back and forth no change. I've removed the backup buzzer too so can't use that to trouble shoot.

Any suggestions on where to start?
Thanks in advance.
lazy D is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-03-2017, 09:12 AM   #2
BGW Sponsor
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 66,611
Default Re: Modified CC DS won't move.

indicates solenoid not activating (clicking) or failing to complete the circuit.
scottyb is offline   Reply With Quote
Unread 07-03-2017, 09:24 AM   #3
Not Yet Wild
 
Join Date: Dec 2009
Posts: 3
Default Re: Modified CC DS won't move.

I'm not hearing any solenoid click at any point. Not when I turn on the key or step on the go pedal. Nada.
lazy D is offline   Reply With Quote
Unread 07-03-2017, 09:34 AM   #4
BGW Sponsor
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 66,611
Default Re: Modified CC DS won't move.

That is the problem.
Find the wiring diagram that fits your cart and check to see that the micro switch on F&R and in the Vglide are working. GL and have a great holiday
Attached Images
File Type: jpg tech tips.JPG (87.9 KB, 0 views)
scottyb is offline   Reply With Quote
Unread 07-03-2017, 08:11 PM   #5
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 8,846
Default Re: Modified CC DS won't move.

If this is a "Series" car with a serial number prefix of "AA" and a lever operated F&R switch, please proceed with this test..... If it's something else, disregard this entire message...

Locate the solenoid. You'll see two large posts and two small posts. On one of the small posts you'll see a small yellow wire. Get a jumper wire with alligator clips on both ends, 2 or 3 feet long is all you'll need. Carefully place the jumper wire on the small post of the solenoid with the small yellow wire. Locate the MAIN negative battery terminal. This is the rear-most battery on the driver's side. The negative terminal has a black wire connected to it that runs through a small hole in the On-Board computer en route to the back of the cart where it connects to the controller. Once you've located the correct battery post, place the other end of the jumper wire on the battery terminal with this wire. Put the car in forward and turn the key on and attempt to drive it. Let me know what happens and we'll proceed further with what you need to do to fix it.
TahoeDawgZ71 is offline   Reply With Quote
Unread 07-03-2017, 08:15 PM   #6
Not Yet Wild
 
Join Date: Dec 2009
Posts: 3
Default Re: Modified CC DS won't move.

Sounds great. I'll have to remove the flip down rear seat to get to it all. I'll try this week. I appreciate the input.
Thanks
LD
lazy D is offline   Reply With Quote
Unread 07-03-2017, 09:40 PM   #7
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,850
Default Re: Modified CC DS won't move.

you joined in 2009 and this is your first problem ?
crash test dummy is offline   Reply With Quote
Unread 07-03-2017, 09:45 PM   #8
Gone Insane
 
Mooncarter's Avatar
Club Car
 
Join Date: Oct 2016
Location: Richmond, VA
Posts: 4,246
Default Re: Modified CC DS won't move.

Quote:
Originally Posted by crash test dummy View Post
you joined in 2009 and this is your first problem ?
8 years and 3 posts. I thought I was lazy!
Mooncarter is offline   Reply With Quote
Unread 07-03-2017, 09:49 PM   #9
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,850
Default Re: Modified CC DS won't move.

3 post today !!!
crash test dummy is offline   Reply With Quote
Unread 07-03-2017, 11:20 PM   #10
Garnet & Gold Certified
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 6,209
Default Re: Modified CC DS won't move.

But look at all the knowledge he has gained and didn't have to test our skillz/non-skillz with questions or issues.....
NoleFan4Ever is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
My New Modified G1 Gas Yamaha
Modified EZ Go won't go Electric EZGO
Modified EZ Go won't go Extreme DC!
Modified D4 Harley Members Rides
My G9 with modified muffler Gas Yamaha


All times are GMT -5. The time now is 01:59 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2018, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.