|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-21-2017, 01:58 PM | #1 |
Not Yet Wild
Join Date: Dec 2016
Posts: 14
|
2 lunges then nothing
Hey gang my 08 pres. lunged in reverse twice then would not move again. The reverse buzzer would sound when it happened then nothing. While pushing it back into the garage the runaway cart was beeping but not any more. Batteries are new this spring. Any ideas? Thanks in advance.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-21-2017, 03:27 PM | #2 |
Not Yet Wild
Join Date: Dec 2016
Posts: 14
|
Re: 2 lunges then nothing
Ok have an update if that helps. Got home after work and thought I would try it again. Cart will still not move but reverse buzzer works again. I plugged it in again and the charger went up to 10v on the meter than slowly dropping. I unplugged it after 15 min and it was still at 5v. The yellow battery light flashed when I unplugged it.
|
08-21-2017, 04:45 PM | #3 |
Gone Wild
Join Date: Apr 2014
Location: Oregon City, Or
Posts: 1,977
|
Re: 2 lunges then nothing
I'd check the batteries with a meter first. Batteries may not be getting/holding a full charge. The usual suspects- batteries/OBC/charger.
PS- check out the "Resetting the OBC" and "Charging System Troubleshooting" in the Stickys at the top of this section. . Last edited by tag50; 08-21-2017 at 04:52 PM.. Reason: PS |
08-21-2017, 04:54 PM | #4 |
Gone Wild
Join Date: Apr 2015
Location: NorCal
Posts: 718
|
Re: 2 lunges then nothing
Let it charge completely until it shuts off and then measure pack voltage with a meter. The flashing dash light when you prematurely unplug usually means the batteries are not charged. Once fully charged, troubleshooting will be easier.
|
08-21-2017, 05:22 PM | #5 |
Not Yet Wild
Join Date: Dec 2016
Posts: 14
|
Re: 2 lunges then nothing
Ok I will try that then report back.
|
08-22-2017, 08:15 AM | #6 |
Not Yet Wild
Join Date: Dec 2016
Posts: 14
|
Re: 2 lunges then nothing
Ok checked the voltage and have 50.5v on the pack. Tried resetting the obc as per the sticky and still get same. Will not move but reverse buzzer sounds.any ideas?? Thanks in advance
|
08-22-2017, 09:31 AM | #7 |
Gone Wild
Join Date: Jul 2016
Location: Charlotte NC
Posts: 1,165
|
Re: 2 lunges then nothing
CorvetteJoe,
Check out the post I have linked below, start on Page 3, post #25 from CTD. This could help you determine if you have a bad controller or motor. http://www.buggiesgonewild.com/elect...nt-move-3.html Good luck and keep us informed. Aflyer |
08-22-2017, 07:09 PM | #8 |
Not Yet Wild
Join Date: Dec 2016
Posts: 14
|
Re: 2 lunges then nothing
Thanks Aflyer will check and report back. Thank yiu
|
08-22-2017, 07:49 PM | #9 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 2 lunges then nothing
Use a T-40 Torx driver to remove the four screws that hold the floormat retainers in place. Pull them gently and remove the floormat from the cart. Remove the small triangular shaped access door in the floor. Locate the MCOR beneath the accelerator. You're going to see two plugs plugged into it. One with 2 wires (green and blue) and one with three wires (white, yellow, and purple). Remove the 2-pin connector from the MCOR. Get a paperclip or a small piece of wire and jump the green and blue wire together within the connector that you unplugged from the MCOR. See if the vehicle will operate. If the vehicle operates with the jumper wire in place, replace the MCOR.
|
08-26-2017, 04:33 AM | #10 |
Not Yet Wild
Join Date: Dec 2016
Posts: 14
|
Re: 2 lunges then nothing
Ok found the problem. MCOR. Tahoe Dawg was right on the money with that one. Thank you for all your input. Great forum. Happy carting!!!!!!
|
|
|
Similar Threads | ||||
Thread | Forum | |||
G9E lunges when you press the accelerator | Electric Yamaha | |||
98' Club Car only lunges | Electric Club Car | |||
97 Ezgo lunges at start | Gas EZGO | |||
1988 EZ Go lunges upon start | Gas EZGO | |||
Cart lunges after lift. what next? | Gas EZGO |