|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
02-19-2018, 09:58 AM | #1 |
Not Yet Wild
Join Date: May 2015
Posts: 13
|
Club Car Precedent stuttering and won't move?
I am at a loss... and looking for some help....
Batteries are 2.5 years Alltrax xct48500 400A solonoid 2ga Upgraded wiring New smart charger, bypassing OBC 6" lift with 22" tires Stock motor Cart was working great for the past 10 months.... this weekend when I attempted to use it, the golf cart would just stutter and barely move. The alltrax xct 48500 is showing a low voltage error and then a stuck solenoid error and saw motors field failure show up. I measuring the battery back voltage at 52.7v across 12x4 batteries. I even checked voltage and it would drop minimally when I hit the accelerator. The throttle mcor is new and throttle response in the alltrax program shows no issue. Is it possible the solenoid went bad? I measured the voltage across the solenoid and it shows approx 15v when I hit full throttle. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-19-2018, 10:36 AM | #2 | |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Club Car Precedent stuttering and won't move?
Quote:
You should get 0v across the Solenoid big posts once the Solenoid closes. Get the new Solenoid from a site sponsor as You also going to need a "Regen Diode" across the big posts. |
|
02-26-2018, 09:24 PM | #3 |
Not Yet Wild
Join Date: May 2015
Posts: 13
|
Re: Club Car Precedent stuttering and won't move?
Ok.... replaced the solonoid.... and the issue still persists.
Is there a way to test the controller? |
02-26-2018, 09:32 PM | #4 |
Gone Wild
Join Date: Apr 2017
Location: SE TN
Posts: 2,209
|
Re: Club Car Precedent stuttering and won't move?
Measure the voltage across the small terminals. See if you got 48v
|
02-26-2018, 10:44 PM | #5 |
Not Yet Wild
Join Date: May 2015
Posts: 13
|
Re: Club Car Precedent stuttering and won't move?
Across the small terminals I get 0v with pedal depressed or not.
|
02-26-2018, 11:40 PM | #6 |
Gone Wild
Join Date: Apr 2017
Location: SE TN
Posts: 2,209
|
Re: Club Car Precedent stuttering and won't move?
Remove the blue/white wire from the solenoid and make a jumper from the small terminal to battery negative. See if the solenoid pulls in. Be careful because the cart might start to run. If it pulls in you have a bad controller hopefully it's less than 2 years old.
|
02-26-2018, 11:47 PM | #7 |
Gone Wild
Join Date: Apr 2017
Location: SE TN
Posts: 2,209
|
Re: Club Car Precedent stuttering and won't move?
I guess I should have said that you are missing the Low/0v coming out of the controller to energize the solenoid. One question for you. Do you have a diode across the solenoid?
|
02-27-2018, 07:13 AM | #8 |
Not Yet Wild
Join Date: May 2015
Posts: 13
|
Re: Club Car Precedent stuttering and won't move?
I do not have a diode as the alltrax xct 48500 (less than 1 years old) has it built in.
I will try removing the blue and white wire and jumper that same small terminal to the battery neg to see if the solonoid engages next. |
02-27-2018, 07:20 AM | #9 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: Club Car Precedent stuttering and won't move?
Where exactly did you measure those 15v in your first post?
Did you disconnect the OBC 6-pin and jumped the wires on the harness or is the OBC still connected? Did you get the Regen diode (not related to this issue)? |
02-27-2018, 09:00 AM | #10 |
Not Yet Wild
Join Date: May 2015
Posts: 13
|
Re: Club Car Precedent stuttering and won't move?
I do not have a regen diode. Unless it is part of the alltrax controller.
15v was measured across the two large posts on the solonoid. OBC was still connected. |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Club car precedent ds Iq won't move... | Electric Club Car | |||
Club Car Precedent won't move | Electric Club Car | |||
Stuttering on acceleration - 98 Club Car Electric | Electric Club Car | |||
Club Car stuttering after deep water | Electric Club Car | |||
Update on my stuttering CC Precedent | Electric Club Car |