04-09-2018, 02:08 PM | #1 |
Not Yet Wild
Join Date: Nov 2010
Posts: 11
|
cart not charging
2006 Precendent cart will not charge. Battery pack 46.8 volts tried different charger reset OBC. When you plug in charger it comes on but goes straight to negative amp reading. any helpideas
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
04-10-2018, 09:32 AM | #2 |
Gone Wild
Join Date: Sep 2010
Posts: 190
|
Re: cart not charging
I am not an expert, and you should be hearing from them soon, but could your OBC just be bad? My charger will do what I guess is an initial check to see if batteries are minimally charged, drop momentarily to zero, then start charging.
|
04-10-2018, 09:38 AM | #3 |
Gone Wild
Join Date: Dec 2017
Location: Montreal, Quebec, Canada
Posts: 1,130
|
Re: cart not charging
I might be wrong as I too am learning but if the batteries are that low they are essentially next ro dead and the charger won't kick in. I have heard others say to charge batteries individually with a 12V charger to bring them up a bit then try the 48 volt charger.
|
04-10-2018, 10:25 AM | #4 |
Gone Wild
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 9,329
|
Re: cart not charging
The negative wire from the charger receptacle is not completing the circuit all the way to Controller B-.
The most likely issue on a Precedent is the SCR inside the OBC failed, but check the 10 ga wire from the negative receptacle socket to the OBC and also the 10ga negative wire out of the OBC that goes to Controller B-. Unless You have 2 defective chargers, what happens is if there is no negative connection, the current that keeps the charger relay ON will cause the ammeter to deflect in the negative direction. If this was a DS instead of a Precedent, that would indicate the fuse on the charger receptacle was blown. |
04-12-2018, 01:07 PM | #5 |
Not Yet Wild
Join Date: Nov 2010
Posts: 11
|
Re: cart not charging
Thanks Sergio you are the man. Ground wire was pinched between frame and battery
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Cart not charging 36v | Electric Yamaha | |||
04 IQ cart not charging | Electric Club Car | |||
Charging 48v using OBC out the cart | Electric Club Car | |||
02 IQ cart not charging | Electric Club Car | |||
cart won't go after charging | Electric Club Car |