|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-25-2018, 08:14 AM | #1 |
Gone Wild
Join Date: Jun 2012
Location: Davie, Florida
Posts: 238
|
POWER ON WITH KEY OFF/on..Please help
Hello All,
I have a 91 club car , 36V. V-Glide wiring setup.. The problem is with the key on or off the cart wants to go.. I took the key switch out and completely disconnected it ( Red Blue wires), the cart still wants to go... If I put the cart in forward it starts to go frward without applying throttle at all.. Where should I look for the issue? Thanks for any help... Ant... |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-25-2018, 12:19 PM | #2 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: POWER ON WITH KEY OFF/on..Please help
Check for a stuck solenoid.
|
08-25-2018, 12:41 PM | #3 |
Gone Wild
Join Date: Jun 2012
Location: Davie, Florida
Posts: 238
|
Re: POWER ON WITH KEY OFF/on..Please help
Not really sure how to check it..
I did a continuity test between the two big terminals and there is continuity there. This is with the key switch not connected.. |
08-25-2018, 12:45 PM | #4 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: POWER ON WITH KEY OFF/on..Please help
I think there should be none. Check voltage on each large post, I think you will find pack voltage.
This is a single solenoid setup right? |
08-25-2018, 12:54 PM | #5 |
Gone Wild
Join Date: Jun 2012
Location: Davie, Florida
Posts: 238
|
Re: POWER ON WITH KEY OFF/on..Please help
36.8 On both terminals...
There's only one solenoid |
08-25-2018, 12:58 PM | #6 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: POWER ON WITH KEY OFF/on..Please help
Replace the solenoid. Do you have another?
|
08-25-2018, 01:02 PM | #7 |
Gone Wild
Join Date: Jun 2012
Location: Davie, Florida
Posts: 238
|
Re: POWER ON WITH KEY OFF/on..Please help
|
08-25-2018, 01:07 PM | #8 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: POWER ON WITH KEY OFF/on..Please help
Tap the side of it and see if it releases. If it does, of course you will need to re-connect the key switch. (Do that anyway) If it does not release, it won't hurt to use as-is until you can get one. Just don't leave the pack mains connected for extended periods. And leave it in neutral when stopping.
Make sure cart is in neutral, or better yet rear wheels off the ground when doing these tests/procedures. |
08-25-2018, 01:08 PM | #9 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: POWER ON WITH KEY OFF/on..Please help
Even if solenoid releases I would still get a new one.
|
08-25-2018, 01:18 PM | #10 |
Gone Insane
Join Date: Oct 2016
Location: Richmond, VA
Posts: 14,214
|
Re: POWER ON WITH KEY OFF/on..Please help
After you get the new solenoid I would check V-Glide adjustment.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Full power in reverse, part power in forward | Electric EZGO | |||
Ezgo dies under power then regains power | Electric EZGO | |||
2005 Precedent starts of powered, then loses power, reverse always power | Electric Club Car | |||
Power Wise Charger worked after board replaced now back to no power | Electric EZGO | |||
have power on ezgo buggy no power light | Electric EZGO |