Club car throttle issue

Btenney · 12-23-2018, 11:53 PM

98 48v ds

Testing resistance vglide is in spec. When not hooked to the cart

All wired in if I test the wires back at controller there way off cart crawls

If I unhook pin 3. Touch the pin with my fingers and touch frame cart will run

I ran fresh wire front to back no change I’m at a stand still not sure what direction to take

I swapped in another controller same issue

On a wiring diagram. There looks to be a resistor right befor the micro switch to the f and r. I don’t see one. In the harness

Golferdave · 12-24-2018, 05:12 PM

Did you install a new V-glide?
5k - 0 ohms on 2&3

Btenney · 12-25-2018, 04:41 PM

Yes. At the glide. It reads right at 2 and 3 its way off

Sergio · 12-25-2018, 06:41 PM

Can you post the value of the readings that are way off?

Make sure the measurements are done with the FNR in Forward so there is no resistor in the circuit.

12-23-2018, 11:53 PM	#1
Btenney Not Yet Wild Join Date: Jul 2016 Posts: 43	Club car throttle issue 98 48v ds Testing resistance vglide is in spec. When not hooked to the cart All wired in if I test the wires back at controller there way off cart crawls If I unhook pin 3. Touch the pin with my fingers and touch frame cart will run I ran fresh wire front to back no change I’m at a stand still not sure what direction to take I swapped in another controller same issue On a wiring diagram. There looks to be a resistor right befor the micro switch to the f and r. I don’t see one. In the harness
Btenney Not Yet Wild Join Date: Jul 2016 Posts: 43

12-24-2018, 05:12 PM	#2
Golferdave Gone Wild Join Date: Dec 2016 Location: Alaska/SoCal Posts: 549	Re: Club car throttle issue Did you install a new V-glide? 5k - 0 ohms on 2&3

12-25-2018, 04:41 PM	#3
Btenney Not Yet Wild Join Date: Jul 2016 Posts: 43	Re: Club car throttle issue Yes. At the glide. It reads right at 2 and 3 its way off
Btenney Not Yet Wild Join Date: Jul 2016 Posts: 43

12-25-2018, 06:41 PM	#4
Sergio Gone Wild Join Date: Sep 2012 Location: Charlotte, NC Posts: 9,329	Re: Club car throttle issue Can you post the value of the readings that are way off? Make sure the measurements are done with the FNR in Forward so there is no resistor in the circuit.

Similar Threads
Thread	Forum
2018 Club Car Onward Throttle Issue	Gas Club Car
2009 club cart with Alltrax xct 300 controller throttle issue	Electric Club Car
2003 Club Car Throttle Issue?	Gas Club Car
Speed and Throttle Issue Troubleshooting. MCOR Issue?	Electric Club Car
Club Car throttle issue under load	Gas Club Car

Today
BGW	Sponsored Links __________________ This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum