lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-03-2019, 06:27 PM   #11
dliw enoG
 
Fairtax4me's Avatar
Club Car
 
Join Date: Dec 2015
Location: Charlottesburg Va
Posts: 2,551
Default Re: 2016 Club Car Precedent just jerks

Does the solenoid click if you just barely press the pedal? Should be able to feel it clunk if you put your finger on it.

Might have a loose connection somewhere or a bad cable crimp. Double check all of the battery and motor connections.
Fairtax4me is online now   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-03-2019, 06:49 PM   #12
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 9,707
Default Re: 2016 Club Car Precedent just jerks

On the monitor page, do the RPMs rise when you begin to go? Or do they stay at zero or state a negative value? Did you do like I mentioned on the previous page and turn off the "enable speed limit" to see if it made a difference?

On another note, I don't know if you purchased this setup from me or not. It's often hard to match up people's actual names with their BGW user names. Regardless even if you didn't buy it from me, please be aware that the phone lines are open M-F 9-5PM Eastern Time, for tech support. If for some reason you can't reach me, the Alltrax tech line is extremely helpful. You can talk to either Will or Ron at Alltrax and they'll either have your issue figured out or they'll have you running in no time.
TahoeDawgZ71 is offline   Reply With Quote
Unread 07-03-2019, 08:37 PM   #13
Not Yet Wild
Club Car
 
Join Date: Jun 2019
Location: Illinois
Posts: 14
Default Re: 2016 Club Car Precedent just jerks

I looked for the speed switch but I did not see what you was talking about, I will double check all the connections. Thanks

Sent from my LM-G820 using Tapatalk
JustCarl is offline   Reply With Quote
Unread 07-03-2019, 10:09 PM   #14
MOD of all BS!
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 11,910
Default Re: 2016 Club Car Precedent just jerks

Quote:
Originally Posted by JustCarl View Post
I looked for the speed switch but I did not see what you was talking about, I will double check all the connections. Thanks

Sent from my LM-G820 using Tapatalk
The speed switch is the 3-wire connector at the motor.
NoleFan4Ever is offline   Reply With Quote
Unread 07-03-2019, 10:11 PM   #15
MOD of all BS!
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 11,910
Default Re: 2016 Club Car Precedent just jerks

Is your controller flashing any "Red" blink codes when you turn the key On?

I have had the Precharge issue happen twice before and both times I found a sticking solenoid bridge. There were MJZ-400's......
NoleFan4Ever is offline   Reply With Quote
Unread 07-04-2019, 06:47 AM   #16
Not Yet Wild
Club Car
 
Join Date: Jun 2019
Location: Illinois
Posts: 14
Default Re: 2016 Club Car Precedent just jerks

No not that I see, like I said earlier I replaced the solenoid.

Sent from my LM-G820 using Tapatalk
JustCarl is offline   Reply With Quote
Unread 07-04-2019, 04:13 PM   #17
Not Yet Wild
Club Car
 
Join Date: Jun 2019
Location: Illinois
Posts: 14
Default Re: 2016 Club Car Precedent just jerks

Ok I rechecked the cart with the computer, and yes the RPM go up when it starts to go, I did see the "enable speed limit" in the software and unchecked it still the same. Checked all the voltage in each battery 8.45 was the lowest. But I did notices when I was running in "monitor mode" that the battery voltage was going up and down as low as 36.8 volts then back up to 50.3 volts with no throttle. All cables are tight and look good. FYI the cart worked fine before installing XCT controller so I don't think it would be batteries.
JustCarl is offline   Reply With Quote
Unread 07-04-2019, 07:50 PM   #18
MOD of all BS!
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 11,910
Default Re: 2016 Club Car Precedent just jerks

That controller will pull more amps and require more from your pack. You may want to hook your DVM to the pack and see if it duplicates what you are seeing. If so, then hook it to each battery, 38v is way to low....
NoleFan4Ever is offline   Reply With Quote
Unread 07-04-2019, 07:52 PM   #19
MOD of all BS!
 
NoleFan4Ever's Avatar
Club Car
 
Join Date: Sep 2011
Location: Florida
Posts: 11,910
Default Re: 2016 Club Car Precedent just jerks

And if you have a bad cable (internally failing) it will do that and usually heat up.
NoleFan4Ever is offline   Reply With Quote
Unread 07-04-2019, 08:02 PM   #20
Not Yet Wild
Club Car
 
Join Date: Jun 2019
Location: Illinois
Posts: 14
Default Re: 2016 Club Car Precedent just jerks

Thanks I will give that a try, I was more than a little surprised when I noticed what it was showing. Just hard to imagine pulling that much more voltage with a stock motor.

Sent from my LM-G820 using Tapatalk
JustCarl is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2016 Club Car Precedent Service Manual Electric Club Car
2016 Club Car Precedent Jerking Electric Club Car
Club Car Precedent Jerks and Stops Electric Club Car
precedent club car jerks Electric Club Car


All times are GMT -5. The time now is 09:36 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.