lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-29-2019, 01:45 PM   #1
Not Yet Wild
 
Join Date: Mar 2018
Posts: 1
Default 96 48v club car has no voltage at solenoid small terminals

So I have an issue with a 96 48v club car. The other day it just stopped moving. I'm pretty sure I narrowed it down to the voltage at the solenoid. I'm not getting any voltage to the small terminals. The ground is good, I jumped the positive post on battery to the other small terminal and the solenoid clicked. The cart jumped when I pressed on pedal. I traced back the wires on that specific terminal, a white/black and a red, but everything looks intact. The white/black runs to a micro switch, with a green/white wire on other end of switch running to the potentimoter. The red wire runs to the controller, small spade terminal labeled 1 in diagrams found on this forum. My question is where does this solenoid terminal get its power from? Does the controller feed along the red wire, or does the black/white feed the power from pontentimoter? No voltage off of either micro switch wire and no voltage at the controller "1" terminal that red wire is ran to.

Sidenote: discovered a burnt wire coming off big post of solenoid running to key switch, green wire, but this wasn't causing the issue. Was still making contact, fixed it and still no voltage at small terminal.

Also, the micro switch that the white/black and green/white are wired to seems to be bad. Suppose to be NC but reads open when not engaged. I replaced switch with a confirmed working one but this still isn't fixing the issue. No voltage off of either wire.

Any insight would be appreciated. Thanks
Attached Images
File Type: jpg 950348vuv0.jpg (64.0 KB, 0 views)
jj972tx is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-29-2019, 02:43 PM   #2
Not Yet Wild
 
Join Date: Sep 2014
Posts: 71
Default Re: 96 48v club car has no voltage at solenoid small terminals

place negative probe of mm on last battery negative

place positive probe on solenoid small post positive

jack up cart press go pedal r u seeing pack voltage? could be wrong but i dont think those micro switches are nc.......

also dont use the word ground when talking golf cart there is no frame ground it is negative
foodaba@juno.com is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Electrical issue. I get 36 volts to both small terminals on solenoid when gas pedal p Electric EZGO
36 volts to two small terminals on solenoid zero when gas pedal pushed Electric EZGO
Voltage drop across solenoid terminals Electric Yamaha
48 volt CC no power to small terminals on solenoid Electric Club Car
Terminals too small for solinoid post Electric EZGO


All times are GMT -5. The time now is 11:35 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.