lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-23-2007, 05:37 PM   #1
Not Yet Wild
 
Join Date: Sep 2007
Posts: 1
Default adci

I HAVE A 1996 ELECTRIC CLUB CAR AND FOR 1 MONTH IT RAN GREAT.NOW IT JUST QUIVERS,THE MOTOR AND DRIVE TRAIN.WHAT DO I DO NEXT? I HAVE BEEN A ELECTRIAN FOR OVER 30 YEARS.
adci is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-23-2007, 05:40 PM   #2
nimda
Club Car
 
Join Date: Jun 2007
Posts: 12,912
Default Re: adci

Check ALL your connections and make sure they are clean and tight. Remove one at a time, clean it, and put it right back on where it came off. More than likely a bad connection...either that or the batteries are dead.
roady89 is offline   Reply With Quote
Unread 09-24-2007, 05:48 AM   #3
Gone Wild
 
tungpo1's Avatar
E-Z-GO
 
Join Date: Dec 2006
Location: St. Johns /Jacksonville
Posts: 2,383
Default Re: adci

Yep sounds like the batts are dead, I had one that did the same thing had to change the batts.
tungpo1 is offline   Reply With Quote
Unread 09-27-2007, 07:38 AM   #4
Just me. .
 
phasetim's Avatar
Club Car
 
Join Date: Sep 2007
Location: Pensacola, FL
Posts: 1,092
Default Re: adci

Is the solenoid giving you a strong click? If so, jack the rear wheel up, check battery pack voltage from b+ to b- across the entire pack... then have someone push the pedal down and see what voltage does, if it drops below 40, change batteries, or connections...... (25 volts if you have a 36 volt car) .... if the batteries dont lose voltage, then you may have a internal motor problem, or if you have a v-glide you may have a broken wiper arm.......
phasetim is offline   Reply With Quote
Unread 09-27-2007, 07:31 PM   #5
mac
Not Yet Wild
 
Join Date: Sep 2007
Posts: 46
Default Re: adci

You may have a problem with the motor's brushes...My 95 had to have the brushes replaced several years ago..
Mac
mac is offline   Reply With Quote
Unread 09-27-2007, 08:19 PM   #6
Just me. .
 
phasetim's Avatar
Club Car
 
Join Date: Sep 2007
Location: Pensacola, FL
Posts: 1,092
Default Re: adci

you can test the motor externally, with a little trouble... you have to remove all the motor terminal wires (carefully, using two wrenches, wd-40 and wire brush).... then with a multimeter test continuity.. there should be continuity between a1, and a2... and continuity between s1, and s2 (or f1, f2)... there should be no continuity between the motor case, and any terminal, and no continuity between the a1/a2 terminals and s1/s2 terminals...

be careful taking nuts off though, as turning them could cause damage...
phasetim is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes



All times are GMT -5. The time now is 04:34 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.