lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 08-12-2009, 06:08 PM   #1
Not Yet Wild
 
Join Date: Aug 2009
Posts: 12
Default club car stop going - need electrical help

:Help: I have a 36 volt electric 1994 club car . Just got it. Put new batteries in. Run OK other than, sometimes it would not got either way. but after pressing the peddle several times it would start going again. Now it will not go at all. I have checked each battery. They all had around 6.5 volts. I checked and cleaned all the connections. I checked power at the motor... on two of the wires there was a constant 38 volts and the other two wires there was 38 volts if the shift lever was in forward or reverse. I also checked micro switches and cleaned the v glide. If power is at the motor why does it not turn and where does the controller come into play?
thidenskog is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 08-13-2009, 09:59 AM   #2
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: club car stop going - need electrical help

When this happens try wiggling the F/R switch instead of the peddle.
Above in the stickies there are several wiring Diagrams , look at the one for you Cart .

Is this the correct one 3 Micros , 1 Solenoid and a VGlide ?
http://www.buggiesgonewild.com/attac...890336vpw2.jpg
GLEEMO is offline   Reply With Quote
Unread 08-13-2009, 10:01 AM   #3
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: club car stop going - need electrical help

OOPS forgot to say Hi and
To Buggies Gone Wild !
GLEEMO is offline   Reply With Quote
Unread 08-13-2009, 12:44 PM   #4
Not Yet Wild
 
Join Date: Aug 2009
Posts: 12
Default Re: club car stop going - need electrical help

Wire diagram is correct . Tried f/r switch and no change . All 4 lead connections on the motor have 37 volt when r/f switch is on in either direction , is that the way it should be ? I noticed the small black and white wire on the controler never energize , should they ? I am starting to think the contorler might be bad . Is there a way to jump motor to see if it is working ?
thidenskog is offline   Reply With Quote
Unread 08-13-2009, 12:47 PM   #5
Gone Crazy
 
miferrel's Avatar
Club Car
 
Join Date: Jun 2008
Location: Mississippi
Posts: 2,176
Default Re: club car stop going - need electrical help

To BGW
miferrel is offline   Reply With Quote
Unread 08-13-2009, 12:48 PM   #6
Not Yet Wild
 
Join Date: Aug 2009
Posts: 12
Default Re: club car stop going - need electrical help

If I knew what each componate was suppost to do and when it was suppose to do it , that would help me . I there a place I can read about this ?
thidenskog is offline   Reply With Quote
Unread 08-13-2009, 12:51 PM   #7
Not Yet Wild
 
Join Date: Aug 2009
Posts: 12
Default Re: club car stop going - need electrical help

Thanks for the warm welcome . And any help you may have for me .
thidenskog is offline   Reply With Quote
Unread 08-13-2009, 01:03 PM   #8
Gone Wild
 
A.D.'s Avatar
 
Join Date: Sep 2008
Posts: 192
Default Re: club car stop going - need electrical help

I believe the Black and White wires you are talking about are coming from th V-Glide and they are for speed controller. They do not have power running through them.
A.D. is offline   Reply With Quote
Unread 08-13-2009, 01:16 PM   #9
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,093
Default Re: club car stop going - need electrical help

IF they come from a v-glide they will read 5K -0 ohms through the full range of the gas peddle .... this is the throrrle position indication signal. It tells the controller how much amperage to let thru to the motor. Do not attempt to test the motor or controller yet....
scottyb is offline   Reply With Quote
Unread 08-13-2009, 01:49 PM   #10
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: club car stop going - need electrical help

YES there is a place where you can read all about each part and test procedures and
Problem Trees to follow for Diagnostics.

It's called the Club Car Maintenance/Service Manual. A Used 1 for your cart will probably
Run $40-$75 , check some of the Site Sponsors above or EBay.
GLEEMO is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
1995 Club Car Ds Series Electrical Issue Electric Club Car
1995 Club car electrical help Electric Club Car
84 Club Car electrical problem Test Post
1990 Club Car won't stop! Electric Club Car


All times are GMT -5. The time now is 04:11 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.