lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 08-16-2009, 07:32 PM   #21
Gone Wild
Club Car
 
Join Date: May 2008
Posts: 772
Default Re: 98 club car limo 48 volt

Quote:
Originally Posted by oxfordlawn View Post
look behind the charge receptacle on the cart, under the seat. There is a round yellow plug that pulls apart with a fuse in it. leave the fuse pushed in on the side attatched to the charge receptacle. Put a jumper wire from the battery pack negative post and attatch to the fuse sticking out of the yellow plug/connector. Thsi bypasses the OBC control and jumps the relay in the charger and turns on the charger. This is easier than removing the cover on charger and unplugging wires from relay and bypassing the relay. Good luck
I agree much easier.. thanks for the info
cwayaustx is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 08-16-2009, 07:44 PM   #22
Runnin' with Scissors
 
bioniccartsandcustoms's Avatar
Club Car
 
Join Date: Aug 2009
Location: In My Shop
Posts: 416
Default Re: 98 club car limo 48 volt

Sounds like the OBC is failing. Give a gentle tug on the grey wire coming out of the carts charge recepticle....easy...it is a soldered connection. These corrode and come loose and will also cause carts charger not to kick on.
bioniccartsandcustoms is offline   Reply With Quote
Unread 08-17-2009, 07:36 AM   #23
Maybe This Weekend :)
 
ChevyRacing75's Avatar
Club Car
 
Join Date: May 2009
Location: Lake Norman, NC
Posts: 6,410
Default Re: 98 club car limo 48 volt

Thanks guys. About to head into work. I will give it a shot after. I hope that works.
Thanks
ChevyRacing75 is offline   Reply With Quote
Unread 08-18-2009, 06:47 PM   #24
Maybe This Weekend :)
 
ChevyRacing75's Avatar
Club Car
 
Join Date: May 2009
Location: Lake Norman, NC
Posts: 6,410
Default Re: 98 club car limo 48 volt

I jumped the wire and it is charging. Can I leave it like this as long as I don't over charge?
ChevyRacing75 is offline   Reply With Quote
Unread 08-18-2009, 08:44 PM   #25
Maybe This Weekend :)
 
ChevyRacing75's Avatar
Club Car
 
Join Date: May 2009
Location: Lake Norman, NC
Posts: 6,410
Default Re: 98 club car limo 48 volt

I'm still charging and the gauge hasn't moved a notch. Is it that slow? It's been about 2 hours.
ChevyRacing75 is offline   Reply With Quote
Unread 08-18-2009, 09:39 PM   #26
Runnin' with Scissors
 
bioniccartsandcustoms's Avatar
Club Car
 
Join Date: Aug 2009
Location: In My Shop
Posts: 416
Default Re: 98 club car limo 48 volt

If batteries are in bad shape, or in deep discharge, it could take a long time for them to come up....if they come up at all. After charging, take your volt meter and hook it up to each battery individualy with alligator clips and from a dead stop accelerate wide open. Do this for each battery...one at a time....and record voltage for each. If not alot of difference in voltage readings, drive the cart until it starts to slow and then test. This will tell you what kind of voltage the batteries are holding under a load. Still sounds like a bad OBC has caused damage to the batteries.
bioniccartsandcustoms is offline   Reply With Quote
Unread 08-19-2009, 07:42 AM   #27
Maybe This Weekend :)
 
ChevyRacing75's Avatar
Club Car
 
Join Date: May 2009
Location: Lake Norman, NC
Posts: 6,410
Default Re: 98 club car limo 48 volt

I think I am taking it in to a club car guy today. Can I get everything fixed and leave the batteries for a week or 2? I understand if they are bad they will die quick but will that mess anything up?
ChevyRacing75 is offline   Reply With Quote
Unread 08-19-2009, 11:28 AM   #28
Runnin' with Scissors
 
bioniccartsandcustoms's Avatar
Club Car
 
Join Date: Aug 2009
Location: In My Shop
Posts: 416
Default Re: 98 club car limo 48 volt

If you get everything fixed, you can leave the cart for 45-60 days and it will be ok. That is a new set of fully charged batteries will be fine for 45-60 days. You are right though, if batteries are bad or weak they will drop off really quick. It shouldn't cause any problems except if your barrerie are reall low, it stresses the OBC and the charger trying to bring them back up.
bioniccartsandcustoms is offline   Reply With Quote
Unread 08-20-2009, 08:27 PM   #29
Maybe This Weekend :)
 
ChevyRacing75's Avatar
Club Car
 
Join Date: May 2009
Location: Lake Norman, NC
Posts: 6,410
Default Re: 98 club car limo 48 volt

Going to shop in am to get new trojan batteries and get the wiring figured out. I will have it back next week. Im ready to get customizing New thread coming soon. Thanks for help guys.
Attached Images
File Type: jpg photo.jpg (191.2 KB, 4 views)
ChevyRacing75 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
What lift kit for Club Car Villager 8 Limo? Lifted Golf Carts
Club Car Lifted Limo Big Block Talk!
club car limo project on eBay Golf Carts and Parts
1997 Club Car limo won't go forward on first two tries Electric Club Car
Club Car Limo Members Rides


All times are GMT -5. The time now is 11:43 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.