lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-14-2009, 05:45 PM   #21
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,060
Default Re: Fully charge but no power

Judge, this cart should not be too hard to fix! It ran but didn't charge ... You changed the obc. Now it charges but doesn't run? Right!? Was a new obc? used? exact match? ....do you have a part #?
scottyb is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 10-14-2009, 07:17 PM   #22
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: Fully charge but no power

Quote:
Originally Posted by j4872 View Post
The batt pack from blk neg (rear battery drivers side) to red + (rear batt pass side) reads 51.4 volt s with no charger plugged in since last night.

The solenoid clicks very loud and performs the same when jumping the 2 large posts on the solenoid.

The 19 volt #'s were from putting the red volt meter wire on the red wire coming off the postive post of the rear bat on pass. side ( as above) and then continuing to follow the path of wires and continued to get similar readings in the 18-19 v range. Not sure if that is a correct procedure however
By jove I think U've got it !
GLEEMO is offline   Reply With Quote
Unread 10-14-2009, 07:30 PM   #23
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: Fully charge but no power

With peddle max the motor should also have 48+Volts.
It sounds like you have either ,

Wired something incorrectly = Double check Triple check
Purchased the wrong OBC = confirm by checking old and new part #,s
or you have fried the POT = confirm by Ohm meter 5K ohms (no throttle) to 0 ohms (with throttle maxed)

If all this fails I would guess that U have arced something across the controller and taken it out.

PS: something just dawned on me from about 6-10 months in the past when a guy ran the wire through the obc backwards,
I argued it was impossable , but he changed it ans Walaa it fixed it ?
GLEEMO is offline   Reply With Quote
Unread 10-14-2009, 08:26 PM   #24
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,060
Default Re: Fully charge but no power

Can we confirm that you got the correct OBC for your cart? A part#?
scottyb is offline   Reply With Quote
Unread 10-14-2009, 09:54 PM   #25
Not Yet Wild
 
Join Date: Oct 2009
Posts: 19
Default Re: Fully charge but no power

It is a new OBC

OLd part #19190
LE9752648602 ver 1.35

NEW Part# 21065-01
LE0936910328 ver 1.358
101909901

I will try and check the OHMs as suggested, but what is POS?

Thanks
Judge
j4872 is offline   Reply With Quote
Unread 10-15-2009, 04:57 AM   #26
Not Yet Wild
 
Join Date: Oct 2009
Posts: 19
Default Re: Fully charge but no power

It is a new OBC

OLd part #19190
LE9752648602 ver 1.35

NEW Part# 21065-01
LE0936910328 ver 1.358
101909901

I will try and check the OHMs as suggested, but what is POT?

Thanks
Judge
j4872 is offline   Reply With Quote
Unread 10-15-2009, 12:16 PM   #27
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: Fully charge but no power

Pot (box) is potentiometer the thing which sends peddle position to the controller
to increase or decrease speed to the motor .

Read this link 99 cc skips throughout powerband
GLEEMO is offline   Reply With Quote
Unread 10-15-2009, 01:43 PM   #28
Not Yet Wild
 
Join Date: Oct 2009
Posts: 19
Default Re: Fully charge but no power

OK I have located the POT. There are 5 wires.

purple and yellow to controller

one to key switch

2 to micro switches



with the ignition on, in forward and depress the acceperator

which one(s) do I check the ohms on

Thanks
Judge
j4872 is offline   Reply With Quote
Unread 10-15-2009, 03:21 PM   #29
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: Fully charge but no power

yellow and purple outputs of the pot

I sent the wrong thread My Bad
Is this Potentiometer bad?
GLEEMO is offline   Reply With Quote
Unread 10-15-2009, 09:16 PM   #30
Not Yet Wild
 
Join Date: Oct 2009
Posts: 19
Default Re: Fully charge but no power

OK I tested the OHMs on the POT. Disconnected the purple and yellow wire from the controller.

Results 0 with no peddle

numbers while depressing peddle different than test page sample

5.1 with full throttle.


Tightened everything again. Took cart out of garage and depressed accelerator. Small shutter, creeps a little then it goes full speed. Similar results in reverse.

Does this sound like the POT

Thanks
Judge
j4872 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Batteries not fully charging Electric Club Car
Drive clutch not fully closing on Workhorse Gas EZGO
electric clubcar loses charge and power quickly Electric Club Car
Charger wont fully charge... Electric EZGO


All times are GMT -5. The time now is 08:15 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.