lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 01-01-2008, 03:22 AM   #1
Not Yet Wild
 
Join Date: Nov 2007
Location: Waukesha, Wisconsin
Posts: 3
Default Where does it mount, Controller and OBC

Hello,

I'm finally getting some time to work on my 1995 Club Car DS.
When I bought it the controller and OBC were removed.
I was told that the controller was bad.
I bought a new controller and was going to install it.
I bought a repair manual to help things along.
My problem is that the manual shows the controller bolting to what looks like two straps.
I have looked at the areas around the batteries, between the batteries and axle and can not see where it mounted.
The book shows how everything should be hooked up but really doesn't help with where they are actually mounted on the cart.
Any help would be greatly appreciated.

Thank You in advance.
37CoupeE is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 01-01-2008, 08:56 AM   #2
Just me. .
 
phasetim's Avatar
Club Car
 
Join Date: Sep 2007
Location: Pensacola, FL
Posts: 1,092
Default Re: Where does it mount, Controller and OBC

right under the bag holder, there are two medal bars, they both mount there, the controller towards the passenger side the obc towards the driver side....
phasetim is offline   Reply With Quote
Unread 01-01-2008, 12:46 PM   #3
Gone Wild
 
floorin04's Avatar
 
Join Date: Dec 2006
Location: The Dark Side
Posts: 676
Default Re: Where does it mount, Controller and OBC

Make sure you mount the obc the correct direction for the ground cable to go thru.Other wise no charge..
floorin04 is offline   Reply With Quote
Unread 01-01-2008, 02:49 PM   #4
Not Yet Wild
 
Join Date: Nov 2007
Location: Waukesha, Wisconsin
Posts: 3
Default Re: Where does it mount, Controller and OBC

Thank You for the information.
I just didn't look far enough to find the straps.
They are right where phasetim said.
I will look at the OBC and hopefully get it in the correct orientation.
Before I try and install the controller and OBC I will remove the batteries.
This will make it easier to get at and give me a chance to clean up that area.
It will also give me a chance to check the rest of the wiring and route it cleanly.
I looked at my battery cables and I will also replace them.
Thanks Again for the help.
37CoupeE is offline   Reply With Quote
Unread 01-01-2008, 03:42 PM   #5
Just me. .
 
phasetim's Avatar
Club Car
 
Join Date: Sep 2007
Location: Pensacola, FL
Posts: 1,092
Default Re: Where does it mount, Controller and OBC

the computer has a medal side and a plastic side.. make sure the plastic side faces your batteries.. that will keep that straight...
phasetim is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Cant figure out how to mount this winch!!! Lifted Golf Carts
G9 motor mount Design Center
G-9 engine mount Design Center
yamaha tie rod mount Gas Yamaha
g9 vanguard mount Gas Yamaha


All times are GMT -5. The time now is 07:51 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.