lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 05-04-2010, 10:19 AM   #1
Not Yet Wild
 
Join Date: May 2010
Posts: 17
Default Motor turns but wont go!

A9723 club cart .push the pedal seems like all the electric are working.But it will not go.Motor turning but the cart vibrates like there something broke in the rear housing....... is there clutches in these rear ends
Mark Kline is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 05-04-2010, 01:38 PM   #2
Not Yet Wild
 
samsonone's Avatar
Club Car
 
Join Date: Mar 2010
Location: jacksonville Fl.
Posts: 49
Default Re: Motor turns but wont go!

batt voltage is low if the car shutter's. either have bad batt's or need's to be charged
samsonone is offline   Reply With Quote
Unread 05-04-2010, 03:16 PM   #3
Not Yet Wild
 
Join Date: May 2010
Posts: 17
Default Re: Motor turns but wont go!

Thats what i keep looking at, but i cheak each batt one at a time a they showing full charge.So im looking at the solienode . when i prss the pedal the motor go,s from slow to fast as u press and depress. So the motor must not be getting good power source.....need sum help
Mark Kline is offline   Reply With Quote
Unread 05-04-2010, 03:31 PM   #4
Not Yet Wild
 
sirboozin's Avatar
E-Z-GO
 
Join Date: May 2010
Location: near pittsburgh
Posts: 32
Default Re: Motor turns but wont go!

not to sure about this cart but. could be the gears in the rearend. or check the drive belt and make sure it isnt slipping or torn
sirboozin is offline   Reply With Quote
Unread 05-04-2010, 04:31 PM   #5
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,977
Default Re: Motor turns but wont go!

Check the Voltage at the Yellow Side of the Solenoid (Large Wire) and at the B- Post of the Controller... Wide Open throttle in forward... tell me what the voltage says.
TahoeDawgZ71 is offline   Reply With Quote
Unread 05-04-2010, 05:00 PM   #6
Not Yet Wild
 
Join Date: May 2010
Posts: 17
Default Re: Motor turns but wont go!

check volts at solenoid yellow side 36 volts check it at B- at wide open thottle and 0 volts in foward wide open
Mark Kline is offline   Reply With Quote
Unread 05-04-2010, 05:36 PM   #7
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,977
Default Re: Motor turns but wont go!

Quote:
Originally Posted by Mark Kline View Post
check volts at solenoid yellow side 36 volts check it at B- at wide open thottle and 0 volts in foward wide open
I'm not understanding your statement.... Where did you place the negative probe when you sensed 36 Volts at the solenoid?

I don't think you understood my test procedure so I'll clarify, I'm sorry. Put your positive probe on the yellow side of the solenoid, and the negative probe on the B- post of the controller, at the same time, and give me a wide open throttle reading.
TahoeDawgZ71 is offline   Reply With Quote
Unread 05-04-2010, 06:05 PM   #8
Not Yet Wild
 
Join Date: May 2010
Posts: 17
Default Re: Motor turns but wont go!

ok i put the pos lead to yell side of solenoid and neg side to b- and im getting 35 volts reading at wide open.. now when the pedel not applyed or the key off i shouid not have power on the yellow side correct..when peddel applyed the solenoid should kick on and off correct....
Mark Kline is offline   Reply With Quote
Unread 05-04-2010, 06:40 PM   #9
Gone Wild
 
DOOmsman's Avatar
Yamaha
 
Join Date: Jul 2008
Location: Reddick IL
Posts: 10,985
Default Re: Motor turns but wont go!

does this cart have hubs that could be stripped?
DOOmsman is offline   Reply With Quote
Unread 05-04-2010, 06:56 PM   #10
Not Yet Wild
 
Join Date: May 2010
Posts: 17
Default Re: Motor turns but wont go!

dont think it does like i was saying motors turns and cart wants to go, but has no power. I can hold the cart still while its WOT...the thing i cant figure out is the cart has 6 six volt batt and i believe its a 48 volt cart.The motor says 48 volt 3.75 hp 97 model with comp....The owner of golf cart says its been like that for 8 years and been runnig fine untill here latley.
Mark Kline is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2005 g22 yamaha wont go? solenoid turns off Electric Yamaha
no left turns on a 99 Gas Club Car
Won't start turns over no run Gas Club Car
ezgo starter generator wont charge battery but will turn motor Gas EZGO
91 2-Stroke EZ GO Motor Rebuild Wont Start Gas EZGO


All times are GMT -5. The time now is 08:13 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.