lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 08-07-2010, 10:22 AM   #1
Getting Wild
 
oldngray's Avatar
Club Car
 
Join Date: May 2009
Location: SW Florida
Posts: 135
Default Not sure of what I have here

The S/n on the car says it is: A9224xxxxxx. However, when I look under the seat, I do not find a Solid state Transformer. This car has the Looped wires running across the Car. Not sure what they are called now.
Any ideas? Also looking for the wiring diagram that shows those wires.
oldngray is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 08-07-2010, 10:30 AM   #2
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,077
Default Re: Not sure of what I have here

Are the 'looped wires' looking like bare bed springs laid on their sides ? You may have a resistor coil cart .....
scottyb is offline   Reply With Quote
Unread 08-07-2010, 10:32 AM   #3
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,989
Default Re: Not sure of what I have here

Quote:
Originally Posted by oldngray View Post
The S/n on the car says it is: A9224xxxxxx. However, when I look under the seat, I do not find a Solid state Transformer. This car has the Looped wires running across the Car. Not sure what they are called now.
Any ideas? Also looking for the wiring diagram that shows those wires.
It's a 36 Volt Resistor car. Almost all of the 36 Volt cars from Club Car used this setup. The only time they ever ran a solid state controller on their golf cars was in 1993-94. It was somewhat of a test run before coming out with their 48V solid state car in 1995. In late 94, the 36V car became a resistor car once again and wasn't changed at all until 2004 when they quit making them altogether
TahoeDawgZ71 is offline   Reply With Quote
Unread 08-07-2010, 10:39 AM   #4
Getting Wild
 
oldngray's Avatar
Club Car
 
Join Date: May 2009
Location: SW Florida
Posts: 135
Default Re: Not sure of what I have here

Thanks, so I can assume it is a 92.
Where can I buy a Wiring Harness for this Car? Looking for a complete Harness.
What Lubricant is used in the Rear End?
Thanks much
oldngray is offline   Reply With Quote
Unread 08-07-2010, 11:02 AM   #5
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,989
Default Re: Not sure of what I have here

Quote:
Originally Posted by oldngray View Post
Thanks, so I can assume it is a 92.
Where can I buy a Wiring Harness for this Car? Looking for a complete Harness.
What Lubricant is used in the Rear End?
Thanks much
Yes it's a 92. You can probably get a wire harness from one of the site sponsors, if not, you can get one from a Club Car dealer. The rear end lubricant is SAE30 Motor Oil.
TahoeDawgZ71 is offline   Reply With Quote
Unread 08-07-2010, 11:05 AM   #6
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,077
Default Re: Not sure of what I have here

That cart is so simple that I dunno if the 4 wires that make it work are even in a harness The diagram is in the stickies at the top of this section......
scottyb is offline   Reply With Quote
Unread 08-07-2010, 11:12 AM   #7
Getting Wild
 
oldngray's Avatar
Club Car
 
Join Date: May 2009
Location: SW Florida
Posts: 135
Default Re: Not sure of what I have here

Thanks for the help, This cart has some crude modifications, the harness is a mess. There must be 20 different splices with wires going every which way. The primary wire from the Motor has been spliced. It would be nice if a new Harness was available at a reasonable price, just have not found any yet.
oldngray is offline   Reply With Quote
Unread 08-07-2010, 11:46 AM   #8
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,077
Default Re: Not sure of what I have here

I am sure the harness is available as David said thru any CC dealer.... there are no wires going to the motor only 4 cables. Is that what is spliced? Can you post pics of this mess?
scottyb is offline   Reply With Quote
Unread 08-07-2010, 03:01 PM   #9
Getting Wild
 
oldngray's Avatar
Club Car
 
Join Date: May 2009
Location: SW Florida
Posts: 135
Default Re: Not sure of what I have here

My bad, wrong terminology, yes the Cables have been spliced and will want to replace them. perhaps I can build my own harness, does not look too complicated.
Thanks
oldngray is offline   Reply With Quote
Unread 08-07-2010, 09:47 PM   #10
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,989
Default Re: Not sure of what I have here

The cables are available separately. I'd highly recommend purchasing an Illustrated Parts List for that car so you'll have part numbers for everything you need. I'd get a book for a 96 or newer. Same system... but the diagram in the book is so much better and easier to read.
TahoeDawgZ71 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes



All times are GMT -5. The time now is 07:05 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.