lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-12-2010, 11:09 PM   #1
Not Yet Wild
 
Join Date: Oct 2010
Posts: 10
Default No Fwd or Rev problem

If anybody can help I have a Electric Club Cart DS A9701/557440 48volt carb that will not travel fwd or rev.It will jerk a little bit.The soleniod doesn't click closed,no power is going to the coil side of it,Battery voltage is 51 volts,and batteries load test good.Key switch and all fuses are good.If I jump over the soleniod the cart will travel fwd and rev ok.Im thinking the throttle module is bad.
If you can help that would be great.
Thanks
408sbfmustang@sbcglobal.net
408sbfmustang is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 10-13-2010, 07:36 AM   #2
Gone Wild
 
Join Date: Feb 2009
Location: Not sure yet
Posts: 500
Default Re: No Fwd or Rev problem

You have either a bad solenoid or a bad OBC. Do a OBC by pass (should be able to find it on this site) and try that first.
FIXEROFCARTS is offline   Reply With Quote
Unread 10-13-2010, 10:06 AM   #3
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: No Fwd or Rev problem

The flow of power to turn on solenoid is KEY switch "ON" to F&R micro "in Gear" to V Glide micro "PEDAL DEPREST" to solenoid. I would start by testing the switch, then the micros on back of F&R control and then the micro inside V Glide for correct operation?
When you jumper the solenoid you are bypassing everything in control circuit before AND INCLUDING the solenoids ability to close contacts?
OLD MEC is offline   Reply With Quote
Unread 10-21-2010, 11:44 PM   #4
Not Yet Wild
 
Join Date: Oct 2010
Posts: 10
Default Re: No Fwd or Rev problem

So all micro switches tested good,I went and grounded the yellow wire on the soleniod and melted the jumper and micro on the v-glide.checked the resistor and diode,resistor ok but the diode was continuity both ways,So I have a diode coming and just to make sure what way does it go?
408sbfmustang is offline   Reply With Quote
Unread 10-22-2010, 12:34 AM   #5
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,069
Default Re: No Fwd or Rev problem

Hope you got a new micro for the Vglide too? The stripe on the diode goes to the positive side of the activation circuit.
scottyb is offline   Reply With Quote
Unread 10-22-2010, 09:46 AM   #6
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: No Fwd or Rev problem

if your jumping the soleniod and the cart is working than replace the soleniod....................................
shadowman is offline   Reply With Quote
Unread 10-25-2010, 04:24 PM   #7
Not Yet Wild
 
Join Date: Oct 2010
Posts: 10
Default Re: No Fwd or Rev problem

So here is what I have done.Installed new style soleniod with the diode pre installed,installed new micro on v-glide.The cart still doesn't activate the soleniod,so I jumped the new side of the soleniod to the battery now it works.So im guessing the On Board Computer is bad since no neg batt signal to the soleniod.Im I correct
408sbfmustang is offline   Reply With Quote
Unread 10-25-2010, 04:42 PM   #8
Gone Wild
 
cheapjeep2's Avatar
Club Car
 
Join Date: Nov 2008
Location: Peachtree City, Georgia
Posts: 1,529
Default Re: No Fwd or Rev problem

I would agree, sounds like OBC.
cheapjeep2 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Good problem bad problem Big Block Talk!


All times are GMT -5. The time now is 08:23 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.